Perkins 904D-E28T - Page 106

Features and Controls..................................... 35
Fire Prevention and Explosion Prevention...... 15
Ether ............................................................ 16
Fire Extinguisher.......................................... 16
Lines, Tubes, and Hoses ............................. 17
Fluid Recommendations ................................. 63
ELC Cooling System Maintenance.............. 66
General Coolant Information ....................... 63
Fluid Recommendations (Engine Oil
Specification)................................................. 69
Engine Oil .................................................... 69
General Lubricant Information..................... 69
Fluid Recommendations (General Fuel
Information) ................................................... 55
Contamination Control Recommendations for
Fuels .......................................................... 62
Diesel Fuel Characteristics.......................... 58
Diesel Fuel Requirements ........................... 56
General Information..................................... 56
Renewable and Alternative Fuels................ 63
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 51
Fuel Conservation Practices ........................... 48
Fuel Related Components in Cold Weather ... 52
Fuel Filters ................................................... 52
Fuel Heaters ................................................ 52
Fuel Tanks ................................................... 52
Fuel System - Prime........................................ 93
Electric Fuel Priming Pump ......................... 93
Fuel System Primary Filter (Water
Separator) Element - Replace....................... 94
Fuel System Primary Filter (Water Separator)
Element for Electric Fuel Priming Pump.... 94
Fuel System Primary Filter/Water
Separator - Drain ........................................... 95
Drain Procedure........................................... 95
Fuel System Secondary Filter - Replace ........ 96
Install the Element ....................................... 97
Remove the Element ................................... 96
Fuel Tank Water and Sediment - Drain ........... 97
Drain the Water and the Sediment .............. 97
Fuel Storage Tanks...................................... 98
Fuel Tank ..................................................... 97
G
Gauges and Indicators .................................... 36
Indicator Lamps ........................................... 37
General Hazard Information............................ 10
Containing Fluid Spillage............................. 12
Dispose of Waste Properly .......................... 13
Fluid Penetration ..........................................11
Inhalation ..................................................... 12
Pressurized Air and Water............................11
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ....................... 12
General Information ........................................ 23
H
High Pressure Fuel Lines ................................ 17
Hoses and Clamps - Inspect/Replace............. 98
Replace the Hoses and the Clamps ............ 98
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 33
M
Maintenance Interval Schedule....................... 75
Daily ............................................................. 75
Every 1000 Service Hours........................... 75
Every 2000 Service Hours........................... 75
Every 3000 Service Hours........................... 75
Every 3000 Service Hours or 2 Years ......... 75
Every 4000 Service Hours........................... 75
Every 4500 Service Hours........................... 75
Every 50 Service Hours ............................... 75
Every 500 Service Hours or 1 Year ............. 75
Every 6000 Service Hours or 3 Years ......... 75
Every Week ................................................. 75
When Required............................................ 75
Maintenance Log........................................... 103
Maintenance Recommendations .................... 72
Maintenance Section....................................... 55
Model View Illustrations .................................. 23
904D-E28T Industrial Engine Views............ 24
904D-E36TA Industrial Engine Views ......... 26
Loose or Off Engine Components ............... 28
Mounting and Dismounting ............................. 17
106 M0108133-04
Index Section