Polaris 200 series User Manual

53
PERIODIC MAINTENANCE
6KRXOGRYHUKHDWLQJRFFXURUWKHJDVVXSSO\IDLOVWRVKXWRIIWXUQRII
WKHPDQXDOJDVFRQWUROYDOYHWRWKHDSSOLDQFH
VENTING SYSTEM INSPECTION
Breathing Hazard - Carbon Monoxide Gas
Breathing carbon monoxide can cause brain damage or
death. Always read and understand instruction manual.
• Flue gases may escape if vent pipe is not connected.
• Be alert for obstructed, sooted or deteriorated vent
system to avoid serious injury or death.
• Do not store corrosive chemicals in vicinity of water
heater.
• Chemical corrosion of flue and vent system can
cause serious injury or death.
• Analyze the entire vent system to make sure that
condensate will not become trapped in a section of
vent pipe and therefore reduce the open cross
sectional area of the vent.
$WOHDVWRQFHD\HDUH[DPLQHWKHYHQWV\VWHP3RLQWVRILQVSHFWLRQ
DUHDVIROORZV
1. &KHFNIRUREVWUXFWLRQVDQGRUGHWHULRUDWLRQRIWKHLQWDNHDLUDQG
RUYHQWSLSLQJDQGWKHLQWDNHDLUDQGYHQWWHUPLQDWLRQV5HSODFH
LPPHGLDWHO\ZKHUHQHHGHG
NOTE: 'RQRWUHDFKLQVLGHWKHYHQWWHUPLQDWLRQZKHQWKHKHDWHU
is in operation.
2. &KHFNDOOYHQWV\VWHPFRQQHFWLRQVIRUOHDNDJHDQGUHSDLURU
UHVHDODVQHFHVVDU\
%HVXUH WKH YHQWSLSLQJ LVSURSHUO\ FRQQHFWHGWR SUHYHQW HVFDSH
RIGDQJHURXVÀXHJDVVHVZKLFKFRXOGFDXVHGHDGO\DVSK\[LDWLRQ
2EVWUXFWLRQVDQGGHWHULRUDWHGYHQWV\VWHPVPD\SUHVHQWVHULRXV
health risk or asphyxiation.
&KHPLFDOYDSRUFRUURVLRQRIWKHÀXHDQGYHQWV\VWHPPD\RFFXU
LIDLUIRUFRPEXVWLRQFRQWDLQVFHUWDLQFKHPLFDOYDSRUV6SUD\FDQ
SURSHOODQWV FOHDQLQJ VROYHQWV UHIULJHUDWRU DQG DLU FRQGLWLRQHU
UHIULJHUDQWVVZLPPLQJSRROFKHPLFDOVFDOFLXPDQGVRGLXPFKORULGH
ZD[HVEOHDFKDQGSURFHVVFKHPLFDOVDUHW\SLFDOFRPSRXQGVZKLFK
DUHSRWHQWLDOO\FRUURVLYH
,I DIWHU LQVSHFWLRQ RI WKH YHQW V\VWHP \RX IRXQG VRRWLQJ RU
GHWHULRUDWLRQVRPHWKLQJLVZURQJ&DOOWKHORFDOJDVXWLOLW\WRFRUUHFW
WKH SUREOHP DQG FOHDQ RU UHSODFH WKH ÀXH DQG YHQWLQJ EHIRUH
UHVXPLQJRSHUDWLRQRIWKHZDWHUKHDWHU
INTEGRATED FILTER PREVENTATIVE MAINTENANCE
7KHKHDWHULVGHVLJQHGWRVKXWGRZQLIWKHSUHVVXUHVZLWFKVHQVHV
WKDWWKHDLULQOHWYHQWRUWKHH[KDXVWYHQWLVUHVWULFWHG,QWKLVFDVHWKH
SUHVVXUHVZLWFKZLOORSHQDQGWKHKHDWHUZLOOJHQHUDWHWKH³%ORFNHG
$LU,QWDNH´IDXOWVHH)DXOWDQG$OHUW0HVVDJHVEHJLQQLQJRQ3DJH
,IWKHWURXEOHVKRRWLQJVHFWLRQRIWKLVPDQXDOLQGLFDWHVWKDWWKHUH
LVDEORFNDJHDWWKHDLULQOHWLQWHJUDWHG¿OWHUQRWHWKHIROORZLQJ
• 7XUQRIIWKHJDVVXSSO\WRWKHZDWHUKHDWHUDWWKHPDQXDOJDV
VKXWRII YDOYH VHH )LJXUH  RQ 3DJH  DQG GLVFRQQHFW
SRZHUWRWKHZDWHUKHDWHU6HH(OHFWULFDO:LULQJRQ3DJH
• 7RLQVSHFWWKH¿OWHUORRVHQWKHKRVHFODPSDWWKHDGDSWRUUXEEHU
ERRWDQGVOLGHWKHSODVWLFSLSHRXWDQGDZD\IURPWKHDGDSWRU
UXEEHUERRW6HH)LJXUHLQ,QWHJUDWHG)LOWHU,QVWDOODWLRQ
• 5HPRYHWKHDGDSWRUUXEEHUERRWFRQWDLQLQJWKHRXWHUFODPVKHOO
KRXVLQJE\WXUQLQJFORFNZLVHDSSUR[LPDWHO\´FPDQG
SXOOLQJRIIRIWKHLQWHUQDOFODPVKHOOKRXVLQJ6HH)LJXUHLQ
,QWHJUDWHG)LOWHU,QVWDOODWLRQ
• 8VLQJ\RXU¿QJHUVRUDVPDOOÀDWEODGHVFUHZGULYHUUHPRYHWKH
¿OWHUPHGLDIURPWKHRXWHUFODPVKHOOKRXVLQJKDQGOHFDUHIXOO\
6HH)LJXUHLQ,QWHJUDWHG)LOWHU,QVWDOODWLRQ
• 7RFOHDQ¿OWHUOLJKWO\WDSWKHEDFNRIWKH¿OWHUVXSSRUWWRGLVORGJH
DQ\ODUJHGHEULV6PDOOHUGHEULVPD\EH
• 5HPRYHGE\XVLQJDYDFXXPFOHDQHUWKH¿OWHUPHGLDPD\EH
FOHDQHGE\GLSSLQJWKH¿OWHUPHGLDLQWRD
• 6ROXWLRQRIZDUPVRDS\ZDWHUDQGULQVLQJLQFOHDQZDWHU'R
QRWVFUXEDOORZWRDLUGU\EHIRUHUHLQVWDOOLQJ
• )LOWHUPHGLDPD\EHFOHDQHGRQDQDYHUDJHWRWLPHVEHIRUH
UHSODFLQJZLWKDQHZ¿OWHUPHGLDLVUHTXLUHG
• 5HLQVWDOO¿OWHUPHGLDE\GRLQJWKHDERYHVWHSVLQUHYHUVHRUGHU
• 7XUQRQWKHJDVVXSSO\DQGUHFRQQHFWSRZHU5HIHUWR(OHFWULFDO
Wiring on Page 33, Control System Operation on Page 36,
DQG6WDUW8SRQ3DJH9HULI\SURSHURSHUDWLRQRIWKHZDWHU
heater before leaving.
7KH ZDWHU KHDWHU PXVW QHYHU EH RSHUDWHG ZLWKRXW WKH ILOWHU
PHGLD LQVWDOOHG  'DPDJHV RU VHUYLFH FDOOV DVVRFLDWHG ZLWK
RSHUDWLQJ WKH KHDWHU ZLWKRXW WKHILOWHU PHGLD LQVWDOOHGDUH QRW
FRYHUHGXQGHUWKHOLPLWHGZDUUDQW\
TEMPERATURE-PRESSURE RELIEF VALVE TEST
Burn hazard.
Hot water discharge.
Keep clear of Temperature-
Pressure Relief Valve
discharge outlet.
,WLVUHFRPPHQGHGWKDWWKH7HPSHUDWXUH3UHVVXUH5HOLHI9DOYH
VKRXOG EH FKHFNHG WR HQVXUH WKDW LW LV LQ RSHUDWLQJ FRQGLWLRQ
every 6 months.
:KHQ FKHFNLQJ WKH 7HPSHUDWXUH3UHVVXUH 5HOLHI 9DOYH
RSHUDWLRQPDNHVXUHWKDWQRRQHLVLQIURQWRIRUDURXQGWKH
RXWOHWRIWKH7HPSHUDWXUH3UHVVXUH5HOLHI9DOYHGLVFKDUJHOLQH
DQG  WKDW WKH ZDWHU GLVFKDUJH ZLOO QRW FDXVH DQ\ SURSHUW\
GDPDJH DV WKH ZDWHU PD\ EH H[WUHPHO\ KRW 8VH FDUH ZKHQ
operating valve as the valve may be hot.
7RFKHFNWKHWHPSHUDWXUHSUHVVXUHUHOLHIYDOYHOLIWWKHOHYHUDW
WKHHQG RI WKH YDOYH VHYHUDOWLPHV 5HIHUWR )LJXUH  EHORZ
7KHYDOYHVKRXOGVHDWSURSHUO\DQGRSHUDWHIUHHO\
,IDIWHUPDQXDOO\RSHUDWLQJWKHYDOYHLWIDLOVWRFRPSOHWHO\UHVHW
DQG FRQWLQXHV WR UHOHDVH ZDWHU LPPHGLDWHO\ FORVH WKH FROG
ZDWHULQOHWWRWKHZDWHUKHDWHUDQGGUDLQWKHZDWHUKHDWHUVHH
'UDLQLQJDQG)OXVKLQJRQ3DJH5HSODFHWKH7HPSHUDWXUH
3UHVVXUH5HOLHI9DOYHZLWKDSURSHUO\UDWHGVL]HGQHZRQHVHH
7HPSHUDWXUH3UHVVXUH5HOLHI9DOYHRQ3DJHIRULQVWUXFWLRQV
RQUHSODFHPHQW
DISCHARGE PIPE
TEMPERATURE-PRESSURE
RELIEF VALVE
Figure 47
,IWKH7HPSHUDWXUH3UHVVXUH5HOLHI9DOYHRQWKHZDWHUKHDWHUZHHSV
RUGLVFKDUJHVSHULRGLFDOO\WKLVPD\EHGXHWRWKHUPDOH[SDQVLRQ

Polaris 200 series Specifications

General

Brand	Polaris
Model	200 series
Category	Heater
Language	English