72
MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Item Hours/
Miles
Frequency Remarks
Carburetor float
bowl
50 hrs. 6 months Drain bowl periodically and
prior to storage
Throttle Cable/ETC
Switch
50 hrs. 6 months Inspect; adjust; lubricate;
replace if necessary
Choke (enricher)
cable
50 hrs. 6 months Inspect; adjust; lubricate;
replace if necessary
Coolant strength 100 hrs. 6 months Inspect strength seasonal-
ly; pressure test system
annually
Drive belt 50 hrs. 6 months Inspect; replace as needed
Steering 50 hrs. 6 months Inspect daily; lubricate
Front suspension 50 hrs. 6 months Inspect; lubricate; tighten
fasteners
Rear suspension 50 hrs. 6 months Inspect; tighten fasteners
Drive chain(s) 50 hrs. 6 months Inspect daily; adjust and lu-
bricate if needed
Spark plug 100 hrs. 12 months Inspect; replace as needed
More often under severe use, such as dirty or wet conditions
Emission Control System Service (California)
Dealer service item
Improperly performing the procedures marked with a could result
in component failure and lead to serious injury or death. Have an
authorized Polaris dealer perform these services.
WARNING
To Next Page
Loading...
Need help?
General
