73
MAINTENANCE AND LUBRICATIO N
Periodic Maintenance Schedule
Item Hours/
Miles
Frequency Remarks
" Rear axle 50 hrs. 6 months Inspect bearings; lube
J
L
Ignition Timing 100 hrs. 12 months Inspect; adjust as needed
J
L
Fuel system 100
hours
12 months Check for leaks at tank
cap, lines, fuel valve, filter,
pump and carburetor; re-
place lines every two years
J Fuel filter 100 hrs. 12 months Replace annually
Radiator 100 hrs. 12 months Inspect; clean external sur-
face
Cooling system
hoses
100 hrs. 12 months Inspect
Spark arrestor 100 hrs. 12 months Clean out
J Clutches (drive and
driven)
100 hrs. 12 months Inspect; clean
Engine mounts 100 hrs. 12 months Inspect
J Brake fluid 200 hrs. 24 months Change every two years
J Front wheel bear-
ings
300 hrs. 36 months Inspect; replace as needed
L
Idle speed As required Adjust
J Toe adjustment As required Periodic inspection; adjust
when parts are replaced
Headlight aim As required Adjust as needed
" More often under severe use, such as dirty or wet conditions
L Emission Control System Service (California)
J Dealer service item
To Next Page
Loading...
Need help?
General
