2.4
Maintenance
L = Lubricate / I = Inspect or Adjust / R = Replace / C = Clean
Item
Frequency / Intervals
150 mi.
(2
40 km)
500 mi.
(800 km)
1000 mi.
(1600 km)
2000 mi.
(3200 km)
Pre-
Season
Fuel Filter Replace every 2,000 miles (3,200km) or every 2 years.
Throttle Lever / Throttle Cable I L L L L
Fuel / Vent Hoses I I I I I
Oil Pump Adjustment I I
Oil Hoses I I I I I
Air Box I I I
Electrical System
Auxiliary Shut-Off Pre-Ride Inspection I
Throttle Safety Switch Pre-Ride Inspection I
Ignition Switch Pre-Ride Inspection I
Headlights / Brake light / Taillights Pre-Ride Inspection I
Hand / Thumbwarmers Pre-Ride Inspection I
PERC Reverse System Pre-Ride Inspection I
Chassis / Suspension
Ski Toe Alignment I I I
Suspension Mounting Bolts Pre-Ride Inspection I
Rear Chain Case Fasteners
2010-2011 Pro-Ride Models
2012-2013 (Bonded Chaincase)
Re-torque three lower fasteners every 1,000 miles (1,600 km).
V
isually Inspect
Steering Fasteners / Linkage / Handlebars Pre-Ride Inspection I
Driveshaft / Jackshaft Bearings L L L L
Ski Fasteners I I I I
Drive Chain Tension I I I I I
Chaincase / Gearcase Oil I R I R I
Track Alignment / Track Tension I I I I I
Rebuildable IFP Shocks
High performance shocks should have oil changed and
r
echarged at the end of every riding season.
Rail Slide Condition I I I I I
Bogie / Wheel Condition / Fastener Bolts I I I I I
Hood / Seat / Chassis / En
gine Compartment C C
Periodic Maintenance Table
To Next Page
Loading...
Need help?
General
