Polaris ATP 330 4x4 2005 User Manual

74
MAINTENANCE AND LUBRICATION
Periodic Maintenance Chart
Perform all services at whichever maintenance interval is reached first.
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Cale ndar Miles
(Km)
J
Steering -- Pre-Ride --
Make adjustments as need-
e
d
S
e
e
P
r
e
R
i
d
e
C
h
e
c
k
l
i
s
t
"
Front suspension -- Pre-Ride --
j
ed. See Pre-Ride Checklist
on pa
g
e 52.
"
Rear suspension -- Pre-Ride --
o
n
p
a
g
e
5
2
.
Tires -- Pre-Ride --
"
Brake fluid level -- Pre-Ride --
"
Brake lever travel -- Pre-Ride --
Brake systems -- Pre-Ride --
Wheels/fasteners -- Pre-Ride --
Frame fasteners -- Pre-Ride --
"
E
Engine oil level -- Pre-Ride --
"
E
Air filter , pre-filter -- Daily -- Inspect; clean often
"
E
Air box sediment
tube
-- Daily -- Drain deposits when visible
Coolant
(if applicable)
-- Daily -- Check level daily, change
coolant every 2 years
Headlamp/tail
lamp
-- Daily -- Check operation; apply
dielectric grease if replacing
"
E
Air filter ,
main element
-- W eekly -- Inspect; replace as needed
Recoil housing -- W eekly -- Drain water as needed,
check often if operating in
wet conditions
"
J
Brake pad wear 10 H Monthly 60 (100) Inspect periodically
Battery 20 H Monthly 125 (200) Check terminals; clean; test
"
Front gearcase oil
(if equipped)
25 H Monthly 155 (250) Inspect level; change yearly
"
Middle gearcase
oil (if equipped)
25 H Monthly 155 (250) Inspect level; change yearly
"
Rear gearcase oil
(if equipped)
25 H Monthly 155 (250) Inspect level; change yearly
"
T ransmission oil 25 H Monthly 155 (250) Inspect level; change yearly
" Perform these procedures more often for vehicles subjected to severe use.
E Emission Control System Service (California)
J Have an authorized Polaris dealer perform these s ervices.

Polaris ATP 330 4x4 2005 Specifications

General

Brand	Polaris
Model	ATP 330 4x4 2005
Category	Offroad Vehicle
Language	English