Vehicles subjected to severe use must be serviced at 50% of the stated interval.
Examples of Severe Use: Frequent immersion in mud, water, or sand, constant
high RPM use, prolonged low-speed heavy load operation, extended idle, short
trip cold weather operation, and prolonged high speed operation.
EVERY 50 HOURS / 1000 MILES (1600 KM) OR 12 MONTHS FOLLOWING
INITIAL BREAK-IN SERVICE
Engine Oil and Filter Change the engine oil and filter.
Engine Air Filter
Inspect air filter; replace as necessary. Ensure
proper installation of filter and airbox cover.
Inspect ducts and screens; clean as necessary.
Spark Arrestor Inspect; clean as needed.
Battery
Check terminals; terminals should be tight and
free of corrosion. Clean, test, and replace as
necessary.
Brake System
Inspect brake pad wear. Inspect hoses for
damage. Replace as needed.
General Lubrication
Inspect, lubricate, and adjust as necessary.
Radiator
Inspect; Clean external surfaces.
Tires
Inspect; Adjust pressure level as needed;
Inspect wear and replace as needed.
Spark Plug Inspect; replace as needed.
Wiring and Connectors
Inspect for wear, routing, and retention. Clean
as necessary.
Front Gearcase Fluid
Change fluid.
Transmission Fluid
Change fluid.
Drive Belt
Inspect, clean, and replace as necessary.
Clutches
Inspect weights, bushings, rollers, wearable
parts; clean; replace worn parts as needed.
Suspension Components /
Alignment*
Inspect front and rear suspension bushings,
and ball joints for loose or worn components;
replace as needed. Inspect shock absorbers for
leaks or damage.
107
MAINTENANCE
To Next Page
Loading...
