EasyManua.ls Logo

Polaris Sportsman 2004 - Page 75

Polaris Sportsman 2004
137 pages
To Next Page IconTo Next Page
To Next Page IconTo Next Page
To Previous Page IconTo Previous Page
To Previous Page IconTo Previous Page
Loading...
72
MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Item Hours/
Miles
Frequency Remarks
" Drive chain(s) 50 hrs. 6 months Inspect daily; adjust and lu-
bricate if needed
L
Spark plug 100 hrs. 12 months Inspect; replace as needed
" Rear axle 50 hrs. 6 months Inspect bearings; lube
J
L
Ignition Timing 100 hrs. 12 months Inspect; adjust as needed
J
L
Fuel system 100
hours
12 months Check for leaks at tank
cap, lines, fuel valve, filter,
pump and carburetor; re-
place lines every two years
J Fuel filter 100 hrs. 12 months Replace annually
Radiator 100 hrs. 12 months Inspect; clean external sur-
face
Cooling system
hoses
100 hrs. 12 months Inspect
J Clutches (drive and
driven)
100 hrs. 12 months Inspect; clean
Engine mounts 100 hrs. 12 months Inspect
J Brake fluid 200 hrs. 24 months Change every two years
J Front wheel bear-
ings
300 hrs. 36 months Inspect; replace as needed
Spark arrestor 300 hrs. 36 months Clean out
L
Idle speed As required Adjust
J Toe adjustment As required Periodic inspection; adjust
when parts are replaced
Headlight aim As required Adjust as needed
" More often under severe use, such as dirty or wet conditions
L Emission Control System Service (California)
J Dealer service item
Improperly performing the procedures marked with a J could result
in component failure and lead to serious injury or death. Have an
authorized Polaris dealer perform these services.
WARNING

Table of Contents

Related product manuals