PowerMax PM - Page 27

36 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

PowerMax Pool Heater

Page 27

Figure 9. Sheet Metal Components.

Table of Contents

Default Chapter2
- Table of Contents2
Section 1.3
General Information3
- Introduction3
- Model Identification3
- Warranty4
- Dimensions4
- Locating the Appliance4
Section 2.6
- Locating Heater with Respect to Pool System Loop6
- Locating Appliance for Correct Horizontal Vent/Ducted Air Distance from Outside Wall6
Venting and Combustion Air6
- Combustion Air6
- Combustion Air from Room6
- Intake Combustion Air7
- Venting7
- Vent Categories7
- Category I Vent8
- Common Venting Systems8
- Category III Vent8
- Locating Vent & Combustion Air Terminals9
- Side Wall Vent Terminal9
Section 3.10
- Side Wall Combustion Air Terminal10
- Vertical Vent Terminal10
- Vertical Combustion Air Terminal10
- Vent Terminals for Outdoor Units10
Gas Supply and Piping10
Section 4A10
Water Connections11
- Automatic Chlorinators11
Section 5.12
- Sensor Locations12
Electrical Connections12
- Main Power13
- Temperature (Operating) Control13
- Programming the Temperature Control13
- Temperature Control Overview13
- Programming Control Parameters13
Section 6.14
- Setpoint - LSP14
- Differential - Dls14
- Pump Operation14
- Heater Purge (Pump Delay) - PD14
- Limit Controls14
Operating Instructions14
- Sequence of Operation14
- Filling the Heater System15
- Operating the Burner and Set up15
- Set up for 0 to 2500 Feet Altitude15
- High Altitude Adjustment and Set up16
- Shutting down the Powermax16
- Spring and Fall Operation Stand-By Service16
- Winter Operation16
Section 7.17
- To Restart the Powermax17
- Therapeutic Pools (Spas)17
Maintenance17
- System Maintenance17
- Appliance Maintenance and Component Description18
- Burners18
- Filter18
- Gas Valves18
- Pool Loop High Limit Control18
- Automatic Reset High Limit Control18
- Temperature Control18
- Ignition Controls18
- Ignitors19
- Ignition Sensors19
- Transformer19
- Blowers19
- Flow Switch19
- Heat Exchanger Coil19
Section 8.20
Trouble Shooting20
- Resolving Lockouts20
- Delayed Ignition - Possible Causes20
- Short Cycling20
- High Gas Consumption20
- Troubleshooting the Pool Heater Temperature Control21
- Troubleshooting Powermax Controls21
Section 9.22
Replacement Parts22
- General Information22
- Parts List22
Pentair Technical Support35