ProBoat ZELOS 48G - Engine Operation and Break-In Process; Vehicle Starting and Running; Breaking in the Engine

Zelos™ 48-Inch Gas Catamaran
Vehicle Starting and Running
Breaking in the Engine
CAUTION: Refertotheincludedengineownersmanualbeforeattemptingtostarttheengine.
Failuretofollowallinstructionscanleadtodamagetoyourvehicle,propertydamageandbodilyinjury.
CAUTION:Alwayskeepallbodyparts,hairanddanglingorlooseitemsawayfromaspinningpropeller,asthese
couldbecomeentangled.
1. Removethecanopy.
2. Poweronyourtransmitter,thenpoweronthe
receiver.
3. Verifythatthereisfuelinthefuelline.Placeyour
thumboverthecarburetorandslowlypullthestarter
cord.Youwillimmediatelyseefuelflowthroughthe
fuellineintothecarburetor.
4. Withtheboatonastandandthepropeller
unobstructed,pullthestartercordinacontinuous
motiontostarttheengine.Theengineshouldstart
within6pulls.
5. Replacethecanopybeforeplacingtheboatinthe
water.
BreakintheenginebyrunningatslowRPMfor1/3tank
andmidRPMfortheremainderofthetank.Ensurewater
isflowingoutoftheautobailers.
NOTICE: Donotadjustcarburetorsettingsduring
break-in.Doingsowillcauseenginedamageor
completeenginefailure.
Whentheboatismovingforward,ensurewaterflows
outofthecoolantoutlets.Ifwaterisnotflowingout
ofthecoolantoutlets,applyaburstofthrottle,notto
exceed1/2throttle.Thiswillforcetheboatuponplane,
allowingwatertoflowthroughthecoolingsystem.
Reduceto1/3throttleaftertheboatisonplaneand
waterisflowingoutthewateroutlets.Iftheboatwill
notplane,returntheboattoshoreandremoveany
obstructions.
Water Blockage
Ifthereisreducedwaterflowduringconsistentspeed,
returntheboattoshoreandinspectitfordebristhatmay
beblockingtherudderinletorthehullwaterpickup.
10
EN