ProBoat ZELOS 48G - Routine Maintenance and Component Care; Maintenance; Water Cooling System

Zelos™ 48-Inch Gas Catamaran
Clutch
Thecentrifugalclutchautomaticallyengageswhenthe
enginerpmisincreased.Besurethattheidlespeed
adjustmentissetlowenoughsothatthepropellerdoes
notrotateatidle.Periodicallydisassembletheclutchand
cleandebrisfromtheclutchshoesandtheinnerclutch
bell.
Clutch Housing Bearing
Forprolongedclutchbearinglife,keepthebearingwell
lubricated(DYNE0100).
Intheeventthatyourboattakesonwaterorflipsandthe
bearinggetswet,clearthebearingofwater.Failingto
dosocanleadtoprematurebearingfailureorcomplete
bearingseizure.
Water Cooling System
Ifwaterdoesnotstreamoutofthewateroutletswhile
theboatismovingforward,immediatelystopthe
engineandcleantheobstructionfromthewatercooling
system.Theengineandmufflerhaveseparatecirculation
connections.
1. Disassembleandcleanthewatercoolingsystemto
removeblockageandpreventoverheating.
2. Replacedamagedparts.
1. Inspecttheengineandenginemountsfordamageor
wear.Replace,cleanorrepairasneeded.
2. Inspecttheconditionofthesparkplugandwire.
Replaceasneeded.
3. Inspectthetunedmufflerfordamageandleaks.
Tightenthescrews.
4. Cleanandcheckthecarburetorforleakageand
smoothoperation.
1mm
Ifworntowithin
1mm,replacewith
PRB292003.Note
thedirectionof
operation(arrows).
Maintenance
16
EN