Procom SSU320RHN-GB - User Manual

1
WARNING: If the information in this manual is not
followed exactly, a fi re or explosion may result caus -
ing property damage, personal injury, or loss of life.
OWNER
’
S MANUAL
VENT-FREE GAS STOVE
This appliance may be installed in an aftermarket*, perma -
nently located manufactured (mobile) home, where not
prohibited by local codes.
This appliance is only for use with the type of gas indicated
on the rating plate. This appliance is not convertible for
use with other gases.
* Aftermarket: Completion of sale, not for purpose of resale, from
the manufacturer.
Consumer : Please retain these instructions for
future use.
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance.
Do not touch any electrical switch; do not use any
phone in your building.
Immediately call your gas supplier from a neighbor’s
phone. Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the fire
department.
Installation and service must be performed by a qualified
installer, service agency, or local gas supplier.
Installer: Please leave these instructions with the
consumer.
CUSTOMER CARE: 1-877-886-5989
PC-SL035A058-0607
WARNING: Improper installation, adjustment, altera -
tion, service or maintenance can cause injury or property
damage. Refer to this manual for correct installation and
operational procedures. For assistance or additional
information consult a qualified installer, service agency,
local gas supplier, or customer service.
WARNING: This is an unvented gas-fired
heater. It uses air (oxygen) from the room in which
it is installed. Provisions for adequate combustion
and ventilation air must be provided. Refer to Air
For Combustion and Ventilation section on page 5
of this manual.
MODEL NO. SSU320RHN-GB SSU320RHL-GB

Summary

IMPORTANT SAFETY INFORMATION

AIR FOR COMBUSTION AND VENTILATION

DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION

Worksheet to determine fresh air needs for heater placement.

Ventilation Air From Inside Building

Ventilation Air From Outdoors

INSTALLATION

CHECK GAS TYPE

CLEARANCES TO COMBUSTIBLES

Minimum Wall and Ceiling Clearances

CONNECTING TO GAS SUPPLY

CHECKING GAS CONNECTIONS

Pressure Testing Gas Supply Piping System

Test Pressures Equal To or Less Than 1;2 PSIG

Pressure Testing Heater Gas Connections

LOG PLACEMENT

OPERATING HEATER

REMOTE CONTROL OPERATING INSTRUCTION

Instructions for operating the heater using the remote control.

SETTING TIMER

SETTING TEMPERATURE

MANUAL OPERATING INSTRUCTIONS

Instructions for operating the heater manually, without remote.

TO TURN OFF GAS TO APPLIANCE

Steps to safely shut off gas supply to the heater.

MANUAL LIGHTING PROCEDURE

Steps for lighting the heater manually using a match.

CLEANING AND MAINTENANCE

INSPECTING FLAME PATTERNS

CLEANING BURNER COMPONENTS

Instructions for cleaning burner injector, pilot air inlet, and cabinet.

MAIN BURNER

REPLACEMENT PARTS

TECHNICAL SERVICE

SPECIFICATIONS

TROUBLESHOOTING

NO SPARK WHEN IGN;OFF IS PRESSED

Troubleshooting steps for when the heater does not spark.

SPARK AT ODS;PILOT BUT NO IGNITION

Troubleshooting when spark is present but ignition fails.

ODS;PILOT HAS FLAME BUT CONTINUES TO SPARK

Troubleshooting when ODS/pilot sparks continuously.

ODS;PILOT HAS FLAME BUT BURNER DOES NOT LIGHT

Troubleshooting when ODS/pilot lights but burner fails to ignite.

DELAYED IGNITION AT BURNER

BURNER BACKFIRING DURING COMBUSTION

HEATER PRODUCES UNWANTED ODORS

HEATER SHUTS OFF IN USE (ODS OPERATES)

Troubleshooting why the heater shuts off due to ODS activation.

GAS ODOR EXISTS EVEN WHEN HEATER IS SHUT OFF

Addressing gas odor issues when the heater is not in operation.

GAS ODOR DURING COMBUSTION

Troubleshooting gas odors occurring while the heater is running.

ILLUSTRATED PARTS BREAKDOWN

Procom SSU320RHN-GB Specifications

General

Brand	Procom
Model	SSU320RHN-GB
Category	Stove
Language	English