4 OPERATION
4.1 BEFORE OPERATING THE HOIST
WARNING:
A GOOD LINE OF COMMUNICATION MUST BE MAINTAINED BETWEEN THE HOIST
OPERATOR AND THE ROOF CREW.
1. Only trained personnel shall operate this equipment. A trained person is one who has read and thoroughly
understands this instruction manual and related equipment manuals and, through training and experience, has shown
knowledge regarding the safe operational procedures.
2. Obey all safety labels provided on your platform hoist and related equipment. These labels warn you of potential
hazards that can cause serious injury. If a label comes off or becomes hard to read, contact Reimann & Georger
Corporation for a replacement.
3. Follow the Pre-hoisting Checklist in the front of this manual before operating.
4. Never use the hoist structure to anchor lifelines, worker harnesses, or other attachments.
5. Always use safety footwear, safety glasses, and head protection devices.
6. Before lifting, insure the safety latch on the hook is not supporting any load. Never hoist over an open doorway.
WARNING:
THE HOISTING OPERATION MUST BE CLEAR OF ALL ELECTRICAL LINES AND
OBSTRUCTIONS TO PREVENT EQUIPMENT DAMAGE AND/OR SERIOUS PERSONAL
INJURY. CONSULT POWER COMPANY BEFORE WORKING NEAR POWER LINES.
7. Hoisting area is to be kept clear of unauthorized personnel. Place barricades or secure the area in such a manner that
if there were an equipment failure, no personnel would be injured.
8. Inspect wire rope for damage, wear, or unraveling. Replace as necessary.
9. Check all hooks and sheaves. Replace as necessary.
4.2 RAISING AND LOWERING THE LOAD
WARNING:
NEVER EXCEED THE RATED LOAD CAPACITY OF 400 POUNDS FOR THE PRO400
HOIST. THE RATED LOAD CAPACITY IS THE MAXIMUM LOAD THAT SHOULD EVER BE
APPLIED TO THE HOIST.
WARNING:
SECURE THE LOAD BEFORE LIFTING.
WARNING:
NEVER STAND IN-LINE WITH THE RAISING OR LOWERING OF THE PLATFORM AT
EITHER THE TOP OR BOTTOM OF THE HOIST TRACK.
12
To Next Page
Loading...