- 5 -
ELECTRICAL-PARTS
REF.NO. PART NO. DESCRIPTION
51 645 056 4468 5P J WIRE,RB501 TO CN501
52 645 056 4000 FUSE,VDE
53 645 056 4000 FUSE,VDE
54 645 056 3713 HEAT SINK
55 645 056 4383 6P J WIRE AWG28 1571
,CN803 TO CD MOTOR
56 645 056 4406 5P J WIRE AWG28 1571
,CN809TO CD LOADER
57 645 057 3491 PWR TRANS,EI66 RADIAL
58 645 050 7182 AC LINE CORD
60 645 053 6984 J WIRE 20624,PICK UP TO CN805
645 048 7163 AC CONNECTOR
PACKING & ACCESSORIES
REF.NO. PART NO. DESCRIPTION
645 057 3439 CARTON CASE,ICC100111-0006
645 056 3881 POLYFOAM LEFT,MAIN LEFT
645 056 3898 POLYFOAM RIGHT,MAIN RIGHT
645 048 7774 POLYBAG,FOR PWR CORD
645 048 7781 POLYBAG,FOR I/B
645 056 3911 POLYBAG,FOR MAIN UNIT
645 057 3651 INSTRUCTION MANUAL
645 056 3690 MAIN SPK BOX
645 050 7182 AC LINE CORD
645 056 3218 REMOCON
645 057 3514 FM ANT,VTA200001-0030
645 056 4208 LOOP ANT ASSY,VTA400002-0010
PARTS LIST
CAUTION : Regular type resistors and capacitors are not listed. To know those values, refer to the schematic diagram.
Regular type resistors are less than 1/4W carbon type and chip resistors.
Regular type capacitors are less than 50V and less than 1000µF of Ceramic type and Electrolytic type.
PRODUCT SAFETY NOTICE
EACH PRECAUTION IN THIS MANUAL SHOULD BE FOLLOWED DURING SERVICING. COMPONENTS IDENTIFIED WITH
THE IEC SYMBOL
!
!!
IN THE PARTS LIST AND THE SCHEMATIC DIAGRAM DESIGNATE COMPONENTS IN WHICH SAFETY
CAN OF SPECIAL SIGNIFICANCE. WHEN REPLACING A COMPONENT IDENTIFIED , USE ONLY THE REPLACEMENT
PARTS DESIGNATED, OR PARTS WITH THE SAME RATINGS OF RESISTANCE, WATTAGE OR VOLTAGE THAT ARE
DESIGNATED IN THE PARTS LIST IN THIS MANUAL. LEAKAGE-CURRENT OR RESISTANCE MEASUREMENTS MUST
BE MADE TO DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT
BEFORE RETURNING THE PRODUCT TO THE CUSTOMER.
REF.NO. PART NO. DESCRIPTION
CABINET & CHASSIS
REF.NO. PART NO. DESCRIPTION
1 645 056 3256 DEC BASE COVER
2 645 056 3393 KNOB PLAY
3 645 056 3478 KNOB LENS
4 645 056 3430 KNOB VOLUME
5 645 056 3485 VOLUME LENS
6 645 056 3287 DEC PANEL
7 645 056 3454 DISPLAY WINDOW
8 645 056 3324 FRONT CAB
10 645 056 3409 KNOB FUNCTION,LEFT
11 645 056 3416 KNOB FUNCTION,CENTRE
12 645 056 3423 KNOB FUNCTION,RIGHT
13 645 056 3676 SPACER
14 645 056 3522 SUPPORT,FOR CON PCB
15 645 049 3690 BEAD FERRITE,SPK WIRE
16 645 056 3782 BKT
17 645 048 7392 WASHER
18 645 056 3744 MICA SHEET,W/1 HOLE 3.3D
19 645 056 3300 CD DOOR
20 645 056 3775 BOTTOM,T=0.8MM GX-K2
22 645 049 3690 BEAD FERRITE,LINE CORD
23 645 048 7354 AC LINE BUSHING
24 645 057 3316 BACK COVER,REAR CAB
28 645 056 3768 TOP COVER,T=0.7MM GX-K2
FIXING PARTS
REF.NO. PART NO. DESCRIPTION
Y01 645 056 3812 SCR 3X8,F TO BTM
Y02 645 056 3812 SCR 3X8,TOP CAB TO BTM
Y03 645 056 3850 SCR 2.5X8,DEC PANEL TO FRONT
Y04 645 056 8473 SCR 3X8,PHONE JACK TO FRONT
Y05 645 056 8473 SCR 3X8,CON. PCB TO F CAB
Y06 645 056 3836 SCR 3X20,CON.PCB TO FRONT
Y07 645 056 3812 SCR 3X8,MAIN PCB TO BTM
Y08 645 056 3812 SCR 3X8,MAIN PCB TO BKT
Y09 645 053 6113 SCR 3X10,BKT TO H/S
Y10 645 053 6113 SCR 3X10,IC TO H/S
Y11 645 056 8473 SCR 3X8,CD PCB TO CD LOADER
Y12 645 056 3843 SCR 3.5X12,CD LOADER TO BTM
Y13 645 056 3805 SCR 4X8,X’FOMER TO BOTTOM
Y14 645 056 8473 SCR 3X8,HEAT SINK TO BTM
Y15 645 048 7576 WASHER,FOR X’FOMER
Y16 645 048 7552 NUT,X’FOMER TO BTM
Y17 645 056 8473 SCR 3X8,AUX JACK TO BACK
Y18 645 056 8473 SCR 3X8,ANT JACK TO BACK
Y19 645 056 8473 SCR 3X8,SUB.JACK TO BACK
Y20 645 056 8473 SCR 3X8,SPK JACK TO BACK
PHONE P.W.BOARD ASSY
REF.NO. PART NO. DESCRIPTION
71 614 325 7356 ASSY,PWB,PHONE(Only initial)
JK501 645 056 3621 PHONE JACK
RB501 645 057 3354 5P CONNECTOR
KEY P.W.BOARD ASSY
REF.NO. PART NO. DESCRIPTION
72 614 325 0654 ASSY,PWB,KEY(Only initial)
TA208 645 048 7965 SW TACT SKHVBE3520,
TUNER/BAND
TA210 645 048 7965 SW TACT SKHVBE3520,MEMORY
TA212 645 048 7965 SW TACT SKHVBE3520,
SOUND PRESET
TA215 645 048 7965 SW TACT SKHVBE3520,PERSET-
TA220 645 048 7965 SW TACT SKHVBE3520,
FUNCTION(ROS MODE)
TA224 645 048 7965 SW TACT SKHVBE3520,
FM MODE (PTY CHECK)
TA231 645 048 7965 SW TACT SKHVBE3520,PRESET+
TA232 645 048 7965 SW TACT SKHVBE3520,TUNE+
TA233 645 048 7965 SW TACT SKHVBE3520,TUNE-
DISPLAY P.W.BOARD ASSY
REF.NO. PART NO. DESCRIPTION
73 614 325 7332 ASSY,PWB,DISPLAY(Only initial)
C0252 403 135 5108 ELECT 4700U M 10V
CN201 645 048 7262 5P CONNECTOR
CN202 645 048 7286 8P CONNECTOR
CN207 645 057 3361 3P HEADER
CN208 645 057 3361 3P HEADER
CN251 645 052 9856 8P CONNECTOR
CN302 645 052 9801 4P CONNECTOR
D0203 645 048 8092 DIODE 1N4148
D0205 645 048 8092 DIODE 1N4148
D0251 645 048 8092 DIODE 1N4148
D0252 645 048 8092 DIODE 1N4148
D0253 645 048 8092 DIODE 1N4148
DP201 645 056 3997 DISPLAY LCD
IC201 645 048 8238 IC 5V43-1 J15,TMP87EP26
L0251 645 048 8429 CHOKE COIL 10UH,AI
To Next Page
Loading...
