Drive
Chain
Tension
Run
vehicle forward
so
that true freeplay
can
be
taken.
To
adjust, remove adjust-
ing screw hair pin. Fully tighten adjust-
ing screw
by
hand then back off only
far enough for hair pin to engage lock-
ing hole and install hair pin.
Turn
clockwise
A015
003 048
Pull
hair pin
This adjustment should provide 3-5 mm
(1/8 -
13/64
in) free-play when mea-
sured at the outer circumference
of
the
brake disc.
.,.,..
CAUTION : Free-play must not
T exceed 5 mm (13/64 in), readjust
if necessary.
•
WARNING : If the specified free-
play
is
not reached with the ten-
sioner screw fully tightened, consult
an
authorized dealer.
Steering
and
Front
Suspension
Mechanism
Visually inspect steering and front sus-
pension mechanism
for
tightness of
components (steering arms, for control
arms and links, tie rods, ball joints, ski
coupler bolts etc.). If necessary replace
or retighten.
Skis
and
Runners
Check the condition
of
the skis and the
ski runners. If worn contact your autho-
rized dealer.
•
WARNING:
Excessively worn
skis and
I
or
ski
runners will hin-
der proper vehicle control.
Steering
and
Ski
Leg
Camber
Adjustment
There are accurate front suspension
geometry adjustments to perform on
this vehicle and they should
be
done
only by
an
authorized dealer.
Exhaust
system
Replace any components which have
rusted or developed cracks or holes.
En-
sure muffler
is
properly secured in its
mount and the ends of retaining springs
have not been over-stretched. The tail
pipe of the muffler should
be
centered
with
the exit hole
in
the bottom pan.
.,.,..
CAUTION : Do not operate vehi-
T cle with muffler disconnected,
serious engine damage will occur .
Engine
Compartment
Keep
clean of grass, twigs, clothes, etc.
These are combustible under certain
conditions.
Air
Filter
Leaving the vehicle uncovered during a
snowfall or riding
in
deep powder snow
may block air filter.
Lift hood and remove air filter from air
intake silencer.
39
To Next Page
Loading...
Need help?
General
