Sony MEX-D30 - User Manual

SERVICE MANUAL
Sony Corporation
Published by Sony Techno Create Corporation
9-893-245-03
2012B33-1
©
2012.02
Ver. 1.2 2012.02
SPECIFICATIONS
MULTIMEDIA AV RECEIVER
E Model
MEX-D30
Brazilian Model
MEX-V30
Model Name Using Similar Mechanism NEW
Mechanism Type
DL-C28DB2-YG2 (MEX-V30)
DL-C28DB2-YG2-SP (MEX-D30)
Monitor section
Display type: Wide LCD color monitor
Dimensions: 3.0 in
System: TFT active matrix
Number of pixels:
76,800 pixels (320 × 240)
Color system:
PAL/NTSC/automatic select
Tuner section
FM
Tuning range: 87.5 – 107.9 MHz
Antenna (aerial) terminal:
External antenna (aerial) connector
Intermediate frequency: 150 kHz
Usable sensitivity: 12 dBf
Selectivity: 20 dB at 400 kHz
Signal-to-noise ratio: 55 dB (mono)
Separation: 30 dB at 1 kHz
Frequency response: 20 – 15,000 Hz
AM
Tuning range: 530 – 1,710 kHz
Antenna (aerial) terminal:
External antenna (aerial) connector
Intermediate frequency: 450 kHz
Sensitivity: 26 μV
DVD/CD Player section
Signal-to-noise ratio: 120 dB
Frequency response: 20 – 20,000 Hz
Wow and flutter: Below measurable limit
Harmonic distortion: 0.03 %
Region code: Labeled on the bottom of the unit
USB Player section
Interface: USB (Full-speed)
Maximum current: 500 mA
Power amplifier section
Outputs: Speaker outputs
Speaker impedance: 4 – 8 ohms
Potência de saída
26 W RMS x4 - 4 ohms, 1 kHz, 10 % THD*, 14,4 V
* medição com um canal ativo
General
Outputs:
Video output terminal (rear)
Audio output terminals (front)
Audio output terminals (rear/sub)
Power antenna (aerial) relay control terminal
Power amplifier control terminal
Inputs:
Antenna (aerial) input terminal
Parking break control terminal
Camera input terminal
AUX audio input terminals (front/rear)
AUX video input terminal
USB signal input c
onnector
Power requirements: 12 V DC car battery
(negative ground (earth))
Dimensions: Approx. 178 u 50 u 191.5 mm (w/h/d)
Mounting dimensions: Approx. 182 u 53 u 165 mm
(w/h/d)
Mass: Approx. 1.7 kg
Supplied accessories:
Remote Commander: RM-X171
Parts for installation and connections (1 set)
Your dealer may not handle some of the above listed
accessories. Please ask the dealer for detailed
information.
Design and specifications are subject to change
without notice.
Weights and dimensions are approximate.
Region code
The region system is used to protect software
copyrights.
The region code is located on the bottom of the unit,
and only DVDs labeled with an identical region code
can be played on this unit.
DVDs labeled can also be played.
If you try to play any other DVD, the message
“Playback prohibited by region code.” will appear on
the monitor screen. Depending on the DVD, no region
code may be labeled even though playing the DVD
is
prohibited by area restrictions.
ALL
Sección del monitor
MEX-D30: MEX-V30:
Tipo de pantalla: Monitor LCD color panorámico
Dimensiones: 3,0 pulgadas
Sistema: matriz activa TFT
Cantidad de píxeles:
76 800 píxeles (320 × 240)
Sist color:
PAL/NTSC/selección automática
Sección del sintonizador
FM
Rango de sintonización: de 87,5 a 107,9 MHz
Terminal de antena:
Conector de antena externa
Frecuencia intermedia: 150 kHz
Sensibilidad útil: 12 dBf
Selectividad: 20 dB a 400 kHz
Relación señal-ruido: 55 dB (mono)
Separación: 30 dB a 1 kHz
Respuesta de frec
uencia: 20 – 15 000 Hz
AM
Rango de sintonización: de 530 a 1 710 kHz
Terminal de antena:
Conector de antena externa
Frecuencia intermedia: 450 kHz
Sensibilidad: 26 μV
Sección del reproductor de CD/DVD
Relación señal-ruido: 120 dB
Respuesta de frecuencia: 20 – 20 000 Hz
Fluctuación y trémolo: inferior al límite medible
Distorsión armónica: 0,03 %
Código de región: etiquetado en la parte inferior de la
unidad
Sección del reproductor USB
Interfaz: USB (velocidad máxima)
Corriente máxima: 500 mA
Sección del amplificador de potencia
Salidas: salidas de altavoz
Impedancia de altavoz: 4 – 8 Ω
Salida Máxima de potencia: 50 W × 4 (a 4 Ω)
* medición con un canal activo
Generales
Salidas:
Terminal de salida de video (posterior)
Terminales de salida de audio (frontal)
Terminales de salida de audio (altavoz potenciador
de graves/posterior)
Terminal de control del relé de la antena
motorizada
Terminal de control del amplificador de potencia
En
tradas:
Terminal de entrada de la antena
Terminal de control de freno de mano
Terminal de entrada de cámara
Terminales de entrada de audio AUX (frontal/
posterior)
Terminal de entrada de video AUX
Conector de entrada de señal USB
Requisitos de alimentación: batería de automóvil de
cc 12 V (masa negativa)
Dimensiones: aprox. 178 × 50 × 191,5 mm (an/al/prof)
Dimensiones de montaje: aprox. 182 × 53 × 165 mm
(an/al/prof)
Peso: aprox. 1,7 kg
Accesorios sumini
strados:
Control remoto: RM-X171
Componentes de instalación y conexiones
(1 juego)
Es posible que su distribuidor no comercialice
algunos de los accesorios que figuran en la lista
anterior. Solicite información detallada.
El diseño y las especificaciones están sujetos a
cambios sin previo aviso.
Los pesos y las dimensiones son aproximativos.
Código de región
El sistema de regiones se utiliza para proteger los
derechos de autor de software.
El código de región está ubicado en la parte inferior de
la unidad y solamente los discos DVD etiquetados con
el mismo código de región pueden ser reproducidos en
esta unidad.
También se pueden reproducir los discos DVD con la
etiqueta .
Si intenta reproducir cualquier otro DVD, aparecerá el
mensaje “Reproducción prohibida por el código de
región” en la pantalla del monitor. Según el tipo de
DVD, no se puede etiquetar ningún código de región
aunque la reproducción del DVD esté prohibida por
las
restricciones del área.
ALL
MEX-D30/V30
Photo: MEX-V30

Summary

Specifications

Monitor Section

Describes display type, dimensions, resolution, and color system.

Tuner Section

Details FM/AM tuning range, sensitivity, selectivity, S/N ratio, separation, and frequency response.

DVD;CD Player Section

Lists signal-to-noise ratio, frequency response, wow/flutter, and harmonic distortion.

USB Player Section

Specifies the USB interface type and maximum current.

Power Amplifier Section

Outlines speaker outputs, impedance, and maximum output power.

General

Covers outputs, inputs, power requirements, dimensions, mass, and supplied accessories.

Servicing Notes

Handling Optical Pick-up Block and Connector

Precautions for ESD, flexible boards, and 28-pin connector.

Laser Diode Emission Check

Safe procedure for checking laser diode emission from the optical pick-up.

Flexible Circuit Board Repair

Instructions for soldering and handling flexible circuit boards during repair.

General Safety and Component Warnings

Covers radiation exposure, laser classification, and critical components.

General Installation and Connection

General Precautions

Lists safety and installation guidelines for operating the unit.

Connection Diagram and Wiring Notes

Illustrates connections and provides details on power, ACC, parking brake, and speakers.

Warning on Antenna Control

Specific warning regarding the connection of power antennas.

Mounting Procedures

Installation Steps and Precautions

Covers parking brake connection, panel handling, mounting parts removal, and ACC warning.

Dashboard and Japanese Car Installation

Guide for dashboard installation and notes for Japanese cars.

Reset Button

Instructions for using the reset button after installation.

Advanced Connection Details

General Connection Cautions

Lists general precautions for wiring and connecting the unit.

Power Supply, Control, and Memory Notes

Details on power leads, antenna control, and memory circuit power.

Speaker Connection Best Practices

Guidance on speaker connection best practices.

Installation Wiring and Precautions

Power Connection Diagram

Illustrates power supply connection based on car connector types.

Mounting Angle and Parking Brake Connection

Guidance on mounting angle and parking brake lead connection.

Front Panel Handling, Reset, and ACC Warning

Instructions for panel handling, reset, and ACC warning.

Disassembly Procedures

Disassembly Flowchart

Outlines the step-by-step order for disassembling the unit.

Cover Removal

Instructions for removing the external cover of the unit.

DVD Deck Assembly Removal

DVD Deck Disconnection and Cable Setting

Steps for disconnecting FPC, removing screws, and cable setup.

Internal Component Removal

Sub Panel and Main Board Removal

Instructions for removing the sub panel assembly and the main board.

Exploded View and Parts List

Unit Exploded Diagram

Visual representation of all components and their assembly order.

Component Part Numbers

List of all part numbers for identification and replacement.

Accessories and Installation Parts

Manuals and Documentation

List of available instruction manuals and documentation.

Installation Hardware

Details of parts required for mounting and connecting the unit.

Sony MEX-D30 Specifications

General

Tuner Bands	FM/AM
CD Playback	Yes
Display Type	LCD
Detachable Faceplate	Yes
Subwoofer Output	Yes
Steering Wheel Control Ready	Yes
MEGA BASS	Yes
Remote Control	Yes
USB Port	Yes
Preset Stations	18 FM
AUX Input	Yes
Bluetooth	Yes (Version 3.0)