Sullair 3010 - Safe Lifting Practices

®SULLAIR®
iv
3700 Operator’s Manual and Parts List
Application Guide .............................................................................. 17
Lubrication Change Recommendations and Maintenance -
Fluid Filter and Separator.................................................................. 18
4 - INSTALLATION................................................................................. 25
Mounting of Compressor................................................................... 25
Ventilation and Cooling ..................................................................... 25
Air-Cooled Compressors ............................................................. 25
Service Air Piping.............................................................................. 26
Pipe Sizing .................................................................................. 26
Use of Auxiliary Receiver / Sump............................................... 26
Isolation Valve(s)......................................................................... 26
Fluid Containment ....................................................................... 27
Coupling Alignment Check................................................................ 27
Fluid Level Check.............................................................................. 27
Electrical Preparation ........................................................................ 27
Motor Rotation Direction Check ....................................................... 28
Fan Motor Rotation Check ................................................................ 28
5 - WS Controller................................................................................... 29
Controller Layout............................................................................... 29
Controller Keypad.............................................................................. 29
LED Display....................................................................................... 29
LED Lights......................................................................................... 31
6 - MAINTENANCE ................................................................................ 33
General.............................................................................................. 33
Daily Operation.................................................................................. 33
Maintenance After Initial 50 Hours of Operation ............................... 33
Maintenance Every 2000 Hours........................................................ 33
Fluid Maintenance ............................................................................ 34
Filter Maintenance............................................................................. 34
Fluid Filter Element Replacement ............................................... 34
Air Filter Maintenance ...................................................................... 34
Air Filter Element Replacement................................................... 35
Separator Maintenance .................................................................... 35
Separator Element Replacement ................................................ 35
Oil Return/Sight Glass Maintenance ........................................... 35
Pressure Regulator Adjustment .................................................. 36
Water Condensate Drain Maintenance ....................................... 36
Control Line Strainer ................................................................... 36
Shaft Coupling Maintenance ....................................................... 37
Troubleshooting - Introduction........................................................... 37
Troubleshooting Guide...................................................................... 38