Sullair SD-400 - Section 6: Spare Parts Lists; Spare Parts List for Sd-220 to Sd-400

INSTALLATION, START-UP & MAINTENANCE MANUAL
SD-220 TO SD-600
REV 04 – 10 Oct 2003
Page 24 of 32
SECTION 6: SPARE PARTS LISTS
6.1. SPARE PARTS LIST FOR SD-220 TO SD-400
SD-220 SD-300 SD-400
1
PRESSURE GAUGE 02250130-190 02250130-190 02250130-190
2
PRESSURE SWITCH 02250130-191 02250130-191 02250130-191
3
PROGRAMABLE LOGIC CONTROLLER (NON-DDS) 02250130-192 02250130-192 02250130-192
4
LIGHT BULB 02250130-203 02250130-203 02250130-203
5
PILOT LIGHT ASSEMBLY WITH GREEN CAP 02250130-204 02250130-204 02250130-204
6
PILOT LIGHT ASSEMBLY WITH RED CAP 02250130-205 02250130-205 02250130-205
7
PILOT LIGHT BASE 02250130-210 02250130-210 02250130-210
8
PILOT LIGHT GREEN CAP 02250130-211 02250130-211 02250130-211
9
PILOT LIGHT RED CAP 02250130-215 02250130-215 02250130-215
10
ON-OFF 2 POSITION SWITCH ASSEMBLY (NON-DDS) 02250130-229 02250130-229 02250130-229
11
ON-OFF 2 POSITION SWITCH HEAD (NON-DDS) 02250130-230 02250130-230 02250130-230
12
ON-OFF SWITCH BLOCK (NON-DDS) 02250130-233 02250130-233 02250130-233
13
FUSE 02250130-237 02250130-237 02250130-237
14
SOLENOID BLOCK 02250130-243 02250130-243 02250130-243
15
SOLENOID REPAIR KIT 02250130-247 02250130-247 02250130-247
16
COIL 02250130-249 02250130-249 02250130-249
17
DUAL SOLENOID 02250130-251 02250130-251 02250130-251
18
SINGLE SOLENOID 02250130-252 02250130-252 02250130-252
19
DESICCANT 02250130-253 02250130-253 02250130-253
20
MUFFLER 02250096-518 02250096-518 02250096-518
21
MOISTURE INDICATOR (NON-DDS) 02250130-254 02250130-254 02250130-254
22
MOISTURE INDICATOR FLR ELEM KIT (NON-DDS) 02250106-667 02250106-667 02250106-667
23
MOISTURE INDICATOR VENT VALVE (NON-DDS) 02250130-257 02250130-257 02250130-257
24
BLUE SILICA GEL REFILL (NON-DDS) 02250130-258 02250130-258 02250130-258
25
PILOT AIR FILTER 02250130-263 02250130-263 02250130-263
26
PILOT AIR FILTER SERVICE VALVE 02250130-135 02250130-135 02250130-135
27
CHAMBER RELIEF VALVE 02250130-298 02250130-298 02250130-298
28
PURGE ADJUSTING VALVE 02250130-300 02250130-300 02250130-300
29
ORIFICE FITTING 02250130-303 02250130-304 02250130-305
30
CHECK VALVE BLOCK 02250130-308 02250130-308 02250130-308
31
OUTLET CHECK VALVE DISC PACK 02250096-547 02250096-547 02250096-547
32
OUTLET CHECK VALVE KIT 02250096-545 02250096-545 02250096-545
33
OUTLET CHECK VALVE FLANGE O-RING KIT 02250096-591 02250096-591 02250096-591
34
OUTLET CHECK VALVE BOLT PACK 02250096-535 02250096-535 02250096-535
35
INLET/EXHAUST CHECK VALVE 3/8 BOUNDED SEAL KIT 02250096-592 02250096-592 02250096-592
36
INLET/EXHAUST VALVE 3/8 BOUNDED SEAL KIT 02250096-592 02250096-592 02250096-592
37
OUTLET CHECK VALVE MOULDED GASKET KIT 02250096-539 02250096-539 02250096-539
38
OUTLET CHECK VALVE GASKET PLATE KIT 02250096-538 02250096-538 02250096-538
39
OUTLET CHECK VALVE HOUSING KIT 02250119-578 02250119-578 02250119-578
40
OUTLET CHECK VALVE ENDPLATE 02250119-579 02250119-579 02250119-579
41
OUTLET CHECK VALVE BOLT PACK 02250119-577 02250119-577 02250119-577
42
INLET/EXHAUST VALVE BLOCK 02250130-310 02250130-310 02250130-310
43
INLET VALVE STEM KIT 02250106-664 02250106-664 02250106-664
44
INLET VALVE STEM PACK 02250096-542 02250096-542 02250096-542
45
INLET VALVE MOULDED GASKET KIT 02250096-540 02250096-540 02250096-540
46
INLET STRIKE PLATE KIT 02250096-540 02250096-540 02250096-540
47
INLET VALVE KIT 02250119-585 02250119-585 02250119-585
48
INLET/EXHAUST VALVE FLANGE O-RING KIT 02250096-591 02250096-591 02250096-591
49
KADDIS DRAIN 02250096-590 02250096-590 02250096-590
50
INLET CYLINDER GASKET KIT 02250096-553 02250096-553 02250096-553
DESCRIPTION#
Part Numbe
r