EasyManua.ls Logo

Superior DRT2035TEP - User Manual

Superior DRT2035TEP
76 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
DRT2000 and DRC2000 Series Direct-Vent Gas Fireplaces
- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neigh-
bor’s phone. Follow the gas supplier’s instruc-
tions.
• If you cannot reach your gas supplier, call the
fi re department.
- Installation and service must be performed by
a qualifi ed installer, service agency or the gas
supplier.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property damage.
AVERTISSEMENT:
RISQUED’INDENDIE OU D’EXPLOSION
Le non-respect Des avertissements de sécurité
pourrait d’entraîner des blessures graves, la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d’essence ni d’autres
vapeurs ou liquides infl ammables dans le voisinage
de cet appareil ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d’allumer d’appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir
des téléphones se trouvant dans le bâtiment où
vous trouvez.
• Sortez immédiatement de bâtiment.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
- L’installation et l’entretien doivent être assurés par
un installateur ou un service d’entretien qualifi é
ou par le fournisseur de gaz.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future
reference.
Installateur : Laissez cette notice avec l’appareil.
Consommateur : Conservez cette notice pour
consultation ultérieure.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only)
or mobile home, where not prohibited by local codes. This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not convertible for use with other gases, unless a certifi ed kit
is used.
Cet appareil peut installé dans une maison préfabriquée (mobile) déjà installée à demeure, si les réglements
locaux le permettent. Ce appareil doit être utilisé uniquement avec le type de gaz indiqué sure la plaque
signalétique. Cet appareil ne peut être converti à d’autres gaz, sauf si une trousse de conversion est utilsée.
Installation and Operation Instructions
Models
CUS
Report No. F13-094
Ce manuel est disponible en francais, simplement en
faire la demande. Numéro de la pièce 900004-02.
P/N 900004-00 REV. J 03/2017
DRT2033TMN
DRT2033TMP
DRT2033TEN
DRT2033TEP
DRC2033TMN
DRC2033TMP
DRC2033TEN
DRC2033TEP
DRC2033RMN
DRC2033RMP
DRC2033REN
DRC2033REP
DRC2035TMN
DRC2035TMP
DRC2035TEN
DRC2035TEP
DRT2033RMN
DRT2033RMP
DRT2033REN
DRT2033REP
DRT2035TMN
DRT2035TMP
DRT2035TEN
DRT2035TEP
DRT2035RMN
DRT2035RMP
DRT2035REN
DRT2035REP
DRC2035RMN
DRC2035RMP
DRC2035REN
DRC2035REP
DRT2040TMN
DRT2040TMP
DRT2040TEN
DRT2040TEP
DRC2040TMN
DRC2040TMP
DRC2040TEN
DRC2040TEP
DRT2040RMN
DRT2040RMP
DRT2040REN
DRT2040REP
DRC2040RMN
DRC2040RMP
DRC2040REN
DRC2040REP
DRT2045DMN
DRT2045DMP
DRT2045DEN
DRT2045DEP
DRC2045DMN
DRC2045DMP
DRC2045DEN
DRC2045DEP
Traditional
Contemporary
P900004-00

Table of Contents

Questions and Answers

  • E
    Elizabeth PollardAug 15, 2025
    How to fix a Superior DRT2035TEP Indoor Fireplace spark igniter that won't light the pilot?
    • D
      Daniel MillerAug 15, 2025
      If the spark igniter on your Superior Indoor Fireplace isn't lighting the pilot, here's what you can check: First, see if there's a spark at the electrode and pilot. If there's no spark, and the electrode wire is connected correctly, the igniter might be defective and need replacement. If there is a spark, try lighting the pilot with a match. If it lights, the gas mixture may be off, requiring a longer purge period. If it still doesn't light, check the gap at the electrode and pilot; it should be about 1/8 inch for a strong spark. If the gap is correct, the pilot might need to be replaced. Also, make sure the gas supply pressure is within the limits specified on the rating plate. Finally, the pilot orifice could be plugged, so try cleaning or replacing it.
  • J
    Jennifer PatelAug 21, 2025
    Why does nothing happen when I turn my Superior DRT2035TEP Indoor Fireplace on or off?
    • E
      Elizabeth BrownAug 21, 2025
      If nothing happens when you turn your Superior Indoor Fireplace ON or OFF, check these items: First, make sure the wall switch plate is set to REMOTE if you're using a remote. Next, ensure that gas is reaching the fireplace by checking the gas supply and gas shutoff valves. Finally, verify the unit is receiving power by checking or replacing the backup batteries behind the wall plate.
  • J
    Joseph ByrdAug 25, 2025
    What to do if Superior DRT2035TEP Indoor Fireplace burner won't light but igniter sparks?
    • R
      Rachel BaileyAug 26, 2025
      If the main burner on your Superior Indoor Fireplace isn't lighting even though the igniter is sparking, check the following: First, ensure that gas is reaching the fireplace by checking the gas supply and shutoff valves. Also, inspect the control compartment for any loose wiring to the valve or ignition module; if you see any loose wires, it's best to call a service technician. Additionally, there might be air in the gas line, which would require purging (it's recommended to call a service technician for this). Finally, make sure the unit is receiving power by replacing the unit's battery backup.
  • J
    John SchmidtAug 28, 2025
    Why does my Superior Indoor Fireplace burner light then go out?
    • F
      Frank AnthonyAug 28, 2025
      If the main burner on your Superior Indoor Fireplace comes on but then goes out, consider these potential issues: First, check that gas is consistently reaching the fireplace by inspecting the gas supply and shutoff valves. Also, examine the control compartment for any loose wiring to the valve or ignition module; if you find any, it's recommended to call a service technician. If the pilot flame is not engulfing the sensor or if there is an obstructed vent system, call a service technician.
  • A
    Adam WallaceAug 31, 2025
    Why does my Superior Indoor Fireplace pilot/burner frequently go out?
    • B
      brucesandovalSep 1, 2025
      If you're experiencing frequent pilot or burner outages with your Superior Indoor Fireplace, it could be due to the pilot flame being too low or blowing too high. This can cause the pilot/valve safety to shut off. Try cleaning and/or adjusting the pilot flame to ensure maximum flame impingement on the thermocouple.
  • A
    Aaron VasquezSep 3, 2025
    Why won't the pilot light stay lit on my Superior DRT2035TEP?
    • A
      Ashley WhiteSep 4, 2025
      If the pilot light on your Superior Indoor Fireplace won't stay lit even after carefully following the lighting instructions, the issue might be a defective pilot generator (thermocouple). Ensure the pilot flame is properly impinging on the thermocouple. Clean and/or adjust the pilot for maximum flame impingement on the thermocouple. Also, check that the connection between the valve and thermocouple is tight and secure.
  • A
    Andrew RodriguezSep 7, 2025
    Why is there soot on the logs and glass of my Superior Indoor Fireplace?
    • J
      Jesse LunaSep 7, 2025
      If you notice soot on the logs and glass of your Superior Indoor Fireplace, here are some possible causes and solutions: * Excessive flame impingement on the logs: Properly position the logs. * Initial fireplace operation: A white film may develop on the glass during the first few fires. Clean the glass after each use (after it has completely cooled). * Improper vent restrictor setting: Open the air shutter by adjusting the air shutter adjustment lever. * Improper air shutter opening: Open the air shutter by pushing in the rod.
  • I
    isabel75Sep 10, 2025
    Why is the flame on my Superior DRT2035TEP poor or blue?
    • M
      Michael ConnerSep 10, 2025
      If you're seeing a poor flame or a blue flame in your Superior Indoor Fireplace, it could be due to a door seal that is not properly aligned. This can cause gaps and air leaks. Try removing and realigning the door to ensure the gasket seal is fully engaged around the door frame.
  • U
    uhermanNov 17, 2025
    What to do if Superior DRT2035TEP pilot is lit but burner won't ignite?
    • J
      Julie MorrisonNov 17, 2025
      If the pilot light is on, but no gas is reaching the burner on your Superior Indoor Fireplace, and the valve knob and burner switch are both in the ON position, consider these possibilities: First, the wall switch or its wiring might be faulty. Check the wall switch and wires for proper connections. You can bypass the wall switch by using a jumper wire across its terminals. If the burner then comes on, the wall switch is defective and needs replacing. If that's not the issue, try bypassing the wall switch wires at the valve with a jumper wire. If the burner comes on, the wires are faulty or have bad connections. Another cause might be that the thermopile isn't generating enough millivolts. Use a millivolt meter to check the thermopile terminals on the gas valve. It should read at least 325...

Summary

General Information

Safety and Your Fireplace

Guidance on fireplace safety and potential hazards.

Important Safety Information

Critical safety guidelines for operating the fireplace safely.

LOCATION

VENT TERMINATION CLEARANCES

Specifies minimum clearances for vent terminations.

MINIMUM CLEARANCES TO COMBUSTIBLES

Details clearances for the fireplace and its vent system.

INSTALLATION

INSTALLATION PREPARATION

INSTALLATION SEQUENCE

Outlines the typical order of installation steps.

VENT SYSTEM PREPARATION

Preparing the vent system for installation.

Install the Horizontal Termination Vent System

Procedures for installing the horizontal vent termination.

Complete the Field Wiring

Verify Proper Fireplace Operation

Steps to verify the fireplace is operating correctly after installation.

OPERATION

MAINTENANCE

Inspecting the venting system

Inspecting the burner flame and pilot flame appearance

Cleaning the glass door

MAINTENANCE SCHEDULE

LIGHTING LABEL, MILLIVOLT GAS VALVE - ENGLISH

LIGHTING INSTRUCTIONS, ELECTRONIC - ENGLISH

TROUBLESHOOTING

Superior DRT2035TEP Specifications

General IconGeneral
BrandSuperior
ModelDRT2035TEP
CategoryIndoor Fireplace
LanguageEnglish

Related product manuals