EasyManua.ls Logo

Superior DRT2033 - User Manual

Superior DRT2033
74 pages
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Installation and Operation Instructions
Superior™ DRT2000 and DRC2000
Direct-Vent Gas Fireplaces
P/N 900004-00 Rev. C 04/2014
Ce manuel est disponible en francais, simplement
en faire la demande. Numéro de la pièce 900004-02.
PFS
®
USC
Models
DRT2033xxx *
DRC2033xxx *
DRT2035xxx *
DRC2035xxx *
DRT2040xxx *
DRC2040xxx *
DRT2045xxx *
DRC2045xxx *
P900004-00
* “xxx” indicates unique model identifiers. This manual covers all Superior™
DRT2000 and DRC2000 models.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Installateur : Laissez cette notice avec l’appareil.
Consommateur : Conservez cette notice pour consultation ultérieure.
A barrier designed to reduce the risk of burns
from the hot viewing glass is provided with this
appliance and shall be installed.
Une barrière conçue pour réduire le risque de brûlure
par le hublot chaude est fournie avec l’appareil et doit
être installé.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile
home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the
rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.
WARNING AVERTISSEMENT AVISO
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
UNE SURFACE VITRÉE CHAUDE PEUT
CAUSER DES BRÛLURES.
LAISSER REFROIDIR LA SURFACE VITRÉE
AVANT D’Y TOUCHER.
NE PERMETTEZ JAMAIS À UN ENFANT DE
TOUCHER LA SURFACE VITRÉE.
EL VIDRIO CALIENTE
CAUSARÁ QUEMADURAS.
USTED DEBE NUNCA TOCAR
EL VIDRIO CALIENTE.
LOS NIÑOS DEBEN NUNCA
TOCAR EL VIDRIO.
WARNING: If the information in these
instructions is not followed exactly, a fire or
explosion may result causing property damage,
personal injury or death.
AVERTISSEMENT : Assurez-vous de bien suivre les
instructions dones dans cette notice pour duire au
minimum le risque d’incindie ou d’explosion ou pour éviter
tout dommage matériel, toute blessure ou la mort.
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
s Do not try to light any appliance.
s Do not touch any electrical switch; do not
use any phone in your building.
s Immediately call your gas supplier from
a neighbor’s phone. Follow the gas
supplier’s instructions.
s If you cannot reach your gas supplier, call
the fire department.
Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
Ne pas entreposer ni utilizer d’essence ni d’autres
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :
s Ne pas tenter d’allumer d’appareil.
s Ne touchez à aucan interrupteur. Ne pas vous
servir des téléphones se trouvant dans le bâtiment
où vous trouvez.
s Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
s Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
L’installation et l’entretien doivent être assurés par un
installateur ou un service d’entretien qualifié ou par le
fournisseur de gaz.

Other manuals for Superior DRT2033

Questions and Answers

  • W
    wmillsAug 14, 2025
    What to do if my Superior DRT2033 Indoor Fireplace spark igniter will not light pilot?
    • R
      Ryan BrownAug 14, 2025
      If the spark igniter on your Superior Indoor Fireplace won't light the pilot, there are several potential causes. First, check for a spark at the electrode and pilot. If there's no spark and the electrode wire is properly connected, the igniter may be defective and needs replacement. If there is a spark, try lighting the pilot with a match. If it lights, the gas mixture may be off, requiring a longer purge period. If it still doesn't light, check the gap at the electrode and pilot; it should be about 1/8 inch for a strong spark. If the gap is correct, the pilot might need replacing. Also, ensure the gas supply pressure is within the limits specified on the rating plate and that the pilot orifice is clean and not plugged.
  • K
    Kimberly JonesAug 17, 2025
    Why is my Superior Indoor Fireplace pilot burning but no gas to burner?
    • D
      Dr. Karina HaleAug 18, 2025
      If the pilot light is on in your Superior Indoor Fireplace, but no gas is reaching the burner, and the valve knob and burner switch are both in the 'ON' position, several issues could be the cause. A defective wall switch or faulty wiring could be the problem; check the connections or try using a jumper wire across the terminals at the wall switch. Also, the thermopile may not be generating enough millivolts; it should read a minimum of 325 millivolts with the optional wall switch OFF. If it reads lower, the thermopile may need replacing. Additionally, a plugged burner orifice could be blocking the gas flow; inspect and clear any blockages. Finally, make sure that only one of the switches is in the ON position.
  • L
    Lori BeckerAug 21, 2025
    What to do if Superior DRT2033 pilot will not stay lit?
    • M
      Morgan DavisAug 21, 2025
      If the pilot light on your Superior Indoor Fireplace won't stay lit after following the lighting instructions, the pilot flame might not be properly impinging on the thermocouple. Ensure the pilot flame makes good contact with the thermocouple. You may need to clean and/or adjust the pilot for maximum flame impingement. Also, check that the connection between the valve and thermocouple is tight and secure.
  • J
    justin89Aug 25, 2025
    What causes frequent pilot/burner outage problem in Superior DRT2033?
    • M
      Matthew DayAug 25, 2025
      Frequent pilot/burner outages in your Superior Indoor Fireplace can be caused by a pilot flame that is too low or too high. Clean and/or adjust the pilot flame to ensure maximum flame impingement on the thermocouple. This will help prevent the pilot/valve safety from dropping out.
  • M
    Mary MorenoAug 27, 2025
    What to do if Superior DRT2033 main burner does not light but the igniter is sparking?
    • C
      Carly BrownAug 27, 2025
      If the main burner on your Superior Indoor Fireplace doesn't light even though the igniter is sparking, first check the gas supply and shutoff valves to ensure gas is reaching the fireplace. Inspect the control compartment for any loose wiring to the valve or ignition module, if necessary, call a service technician. If there is air in the gas line, purge the gas line of air, if required, call a service technician. Also, check and replace the unit battery backup.
  • K
    Kendra HillAug 31, 2025
    What to do if nothing happens when Superior DRT2033 is turned ON/OFF?
    • M
      Marissa WangAug 31, 2025
      If nothing happens when you turn your Superior Indoor Fireplace ON or OFF, first ensure that the wall switch plate is set to REMOTE. Next, check the gas supply and gas shutoff valves to confirm that gas is reaching the fireplace. Finally, check or replace the backup batteries behind the wall plate.
  • J
    Jennifer ShepherdSep 3, 2025
    What causes soot on the logs and glass of my Superior DRT2033?
    • J
      Jake GarciaSep 3, 2025
      Soot on the logs and glass of your Superior Indoor Fireplace can result from several factors. Ensure the logs are properly positioned. A white film may develop on the glass during initial operation of the fireplace. Clean the glass after each use until the film disappears. Check and adjust the vent restrictor setting and air shutter opening according to the instructions in this manual.
  • A
    austinbrandonSep 7, 2025
    Why does my Superior DRT2033 Indoor Fireplace main burner come on but then goes out?
    • E
      Elizabeth DicksonSep 7, 2025
      If the main burner of your Superior Indoor Fireplace comes on but then goes out, check the gas supply and gas shutoff valves to ensure gas is reaching the fireplace. Inspect the control compartment for any loose wiring to the valve or ignition module, if necessary, call a service technician. Also, if the pilot flame is not engulfing the sensor or the vent system is obstructed, call a service technician.
  • S
    Steven DonovanSep 10, 2025
    Why does my Superior DRT2033 have poor flame and/or blue flame?
    • L
      Lisa HendersonSep 10, 2025
      A poor or blue flame in your Superior Indoor Fireplace can be caused by a door seal that is not properly aligned, leading to gaps and air leaks. Remove and realign the door to ensure the gasket seal is fully engaged around the door frame.

Summary

General Information

Important Safety Information

Critical safety instructions and warnings for the fireplace operation and installation.

Packaging

Details on the components included with the fireplace models upon delivery.

Introduction

Overview of the fireplace features, design, and application types.

Codes and Standards

Compliance information regarding safety standards and installation codes.

FIREPLACE INSTALLATION, OPERATION, AND MAINTENANCE NOTICES

Installation

Requirements for the Commonwealth of Massachusetts

Specific installation requirements for Massachusetts including licensing and connector length.

Manufactured Home Requirements

Guidelines for installing the fireplace in manufactured or mobile homes.

Vent Termination Clearances

Specifies required clearances for vent terminations to combustibles and building structures.

Minimum Clearances to Combustibles

Details minimum clearance distances from the fireplace unit to combustible materials.

Installation Sequence

Outlines the step-by-step procedure for installing the fireplace unit and its components.

Wiring

Instructions for connecting electrical power for millivolt and electronic fireplace systems.

ATTACH THE SAFETY-IN-OPERATION WARNINGS

Attaching Safety-in-Operation Warnings

Guidance on properly affixing safety instruction labels to the fireplace controls.

GAS CONVERSION KITS

Installing Gas Conversion Kits

Procedure for converting the fireplace between natural gas and propane fuels.

Operation

Burn-in Period

Information regarding odors and initial operation for new fireplaces.

Gas Controls

Details on locating and understanding millivolt and electronic gas controls.

Installing the logs, volcanic stone, and glowing embers

Instructions for placing decorative elements for proper flame appearance.

Installing and removing the glass door

Installing the glass door

Step-by-step guide for correctly mounting the fireplace glass door.

Removing the glass door

Procedure for safely detaching and storing the fireplace glass door.

MAINTENANCE

Inspecting the venting system

Procedure for checking the vent system for blockages or damage.

Inspecting the burner flame appearance

Guidance on checking flame patterns for proper combustion and appearance.

Cleaning the glass door

Instructions for cleaning fireplace glass without scratching or damage.

MAINTENANCE SCHEDULE

ACCESSORY COMPONENTS

Forced Air Kits

Information on available blower kits for enhanced air circulation.

Termination Guard Kits

Details on guards used to cover exterior vent terminations.

Thermostatic Control Kits

Overview of available thermostat and remote control options.

LIGHTING INSTRUCTIONS

Millivolt Gas Valve

Step-by-step guide to lighting the pilot and burner for millivolt systems.

Electronic Gas Valve

Procedure for lighting the pilot and burner for electronic ignition systems.

TROUBLESHOOTING

REPLACEMENT PARTS

WARRANTY

Superior DRT2033 Specifications

General IconGeneral
BrandSuperior
ModelDRT2033
CategoryIndoor Fireplace
LanguageEnglish

Related product manuals