Superior DRT3540 Series - User Manual

Installation and Operation Instructions
Superior
TM
DRT/DRC3500 Series Direct-Vent Gas
Fireplaces
P/N 900298-00 Rev. A 10/2014
Ce manuel est disponible en francais, simplement
en faire la demande. Numéro de la pièce 900285-03.
PFS
®
USC
Models
DRT3535xxx*
DRC3535xxx*
DRT3540xxx*
DRC3540xxx*
DRT3545xxx*
DRC3545xxx*
P900298-00
* “xxx” indicates unique model identifiers.
This manual covers all Superior
TM
DRT/DRC3500 models.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Installateur : Laissez cette notice avec l’appareil.
Consommateur : Conservez cette notice pour consultation ultérieure.
A barrier designed to reduce the risk of burns
from the hot viewing glass is provided with
this appliance and shall be installed for
the protection of children and other at-risk
individuals.
L’écran pare-étincelles fourni avec ce foyer réduit le
risque de brûlure en cas de contact accidentel avec la
vitre chaude et doit être installé pour la protection Des
enfants et Des personnes à risques.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile
home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the
rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.
Cet appareil peut installé dans une maison préfabriquée (mobile) déjà installée à demeure, si les réglements
locaux le permettent. Ce appareil doit être utilisé uniquement avec le type de gaz indiqué sure la plaque
signalétique. Cet appareil ne peut être converti à d’autres gaz, sauf si une trousse de conversion est utilsée.
— Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neigh-
bor’s phone. Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the re
department.
— Installation and service must be performed by a
qualified installer, service agency or the gas sup-
plier.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result
in serious injury, death, or property damage.
AVERTISSEMENT:
RISQUED’INDENDIE OU D’EXPLOSION
Le non-respect Des avertissements de sécurité
pourrait d’entraîner des blessures graves, la mort
ou des dommages matériels.
— Ne pas entreposer ni utilizer d’essence ni d’autres
vapeurs ou liquides inflammables dans le voisin-
age de cet appareil ou de tout autre appareil.
— QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d’allumer d’appareil.
• Ne touchez à aucan interrupteur. Ne pas vous
servir des téléphones se trouvant dans le bâti-
ment où vous trouvez.
• Sortez immédiatement de bâtiment.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le service des incindies.
— L’installation et l’entretien doivent être assurés par
un installateur ou un service d’entretien qualifié
ou par le fournisseur de gaz.
Report No. 13-094

Summary

Safety Warnings and Precautions

Fire and Explosion Hazard Warnings

Critical warnings about fire and explosion risks, including gas leak procedures.

Hot Glass and Surface Warnings

DANGER/PELIGRO notices regarding extremely hot glass and fireplace surfaces.

General Fireplace Safety Guidelines

Essential safety advice for fireplace operation, including child safety and clearances.

General Information and Requirements

Important Safety Information

Comprehensive safety guidelines covering appliance operation and potential hazards.

Codes and Standards Compliance

Compliance information with national and local safety standards for installation.

Manufactured Home and Location Requirements

Specific installation requirements for manufactured homes and location selection.

Installation Procedures

Vent Termination Clearances

Guidelines for required clearances for vertical and horizontal vent terminations.

Minimum Clearances to Combustibles

Specifies minimum distances from the fireplace to combustible materials.

Installation Preparation and Sequence

Covers preparation steps like framing and the overall installation sequence.

Vent System Installation

Detailed instructions for selecting and installing vertical and horizontal vent systems.

Gas and Electrical Connections

Procedures for connecting gas lines and completing electrical field wiring.

Finishing and Safety Labeling

Installing hoods, barriers, finishing materials, and safety labels.

Operation and Control

Remote Control System Operation

Instructions on initializing and operating the remote control for fireplace functions.

Flame Appearance and Adjustment

Guidance on adjusting the air shutter for optimal flame appearance and preventing soot.

Installing Logs and Decorative Media

Procedures for correctly placing logs, embers, and volcanic stone for proper function.

Lighting Instructions

Step-by-step guide for safely lighting the fireplace pilot and main burner.

Maintenance and Troubleshooting

Scheduled Maintenance Tasks

Outlines required annual and periodic maintenance tasks for the fireplace.

Troubleshooting Common Issues

Provides solutions for common problems encountered with electronic and ignition systems.

Parts, Warranty, and Contact

Replacement Parts Identification

Lists catalog numbers and descriptions for installer and homeowner replacement parts.

Product Warranty Information

Details the 20-year limited warranty, coverage, exclusions, and claim procedures.

Superior DRT3540 Series Specifications

General

Brand	Superior
Model	DRT3540 Series
Category	Indoor Fireplace
Language	English