Superior DT-600CMN - User Manual

1
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS
P/N 725,032M REV. H 11/2004
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
DIRECT-VENT
500/600/800 SERIES
MODELS
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
DR-500 MODEL SHOWN
sledoMtlovilliMsledoMcinortcelE
NMC005-DPMC006-TDNEC005-DPEC006-TD
PMC005-DNMC006-RDPEC005-DNEC006-RD
NMC005-TDPMC006-RDNEC005-TDPEC006-RD
PMC005-TDNMC008-DPEC005-TDNEC008-D
NMC005-RDPMC008-DNEC005-RDPEC008-D
PMC005-RDNMC008-TDPEC005-RDNEC008-TD
NMC006-DPMC008-TDNEC006-DPEC008-TD
PMC006-DNMC008-RDPEC006-DNEC008-RD
NMC006-TDPMC008-RDNEC006-TDPEC008-RD
OTL Report No. 116-F-13-4

Summary

General Information and Safety

High Temperature and Material Safety

Warns about high surface temperatures and prohibits burning non-gas materials.

Operation and Care

Maintenance Schedule

Annual Maintenance Tasks

Tasks to perform annually, specifying who performs them and the procedure.

Front Glass Enclosure Panel

Panel Removal and Installation

Step-by-step instructions for removing and reinstalling the front glass enclosure panel.

Burner Adjustment

Air Shutter Adjustment Procedure

Log Placement

Appliance Checkout Procedures

Millivolt Gas Valve Lighting Instructions

Pre-Lighting Safety Procedures

Essential safety precautions and gas leak checks before lighting the millivolt pilot.

Millivolt Pilot Lighting Steps

Detailed instructions for safely lighting the millivolt pilot and operating the appliance.

Millivolt Appliance Shutdown

Electronic Ignition Lighting Instructions

Electronic Safety and Gas Checks

Essential safety measures and gas leak detection before lighting electronic ignition.

Electronic Ignition Lighting Steps

Detailed instructions for lighting the electronic ignition system and operating the appliance.

Electronic Appliance Shutdown Procedure

Troubleshooting Millivolt Gas Control System

Millivolt Ignitor and Pilot Issues

Addresses common problems like spark ignitor failure and pilot not staying lit.

Millivolt Burner and Outage Problems

Covers issues like no gas to the burner and frequent pilot or burner outages.

Troubleshooting Electronic Ignition System

Electronic Ignition Startup Failures

Solutions for when the burner fails to light or shuts off unexpectedly.

Superior DT-600CMN Specifications

General

Brand	Superior
Model	DT-600CMN
Category	Indoor Fireplace
Language	English