Superior DT-600CEN - User Manual

1
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS
P/N 725,032M REV. H 11/2004
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
DIRECT-VENT
500/600/800 SERIES
MODELS
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
DR-500 MODEL SHOWN
sledoMtlovilliMsledoMcinortcelE
NMC005-DPMC006-TDNEC005-DPEC006-TD
PMC005-DNMC006-RDPEC005-DNEC006-RD
NMC005-TDPMC006-RDNEC005-TDPEC006-RD
PMC005-TDNMC008-DPEC005-TDNEC008-D
NMC005-RDPMC008-DNEC005-RDPEC008-D
PMC005-RDNMC008-TDPEC005-RDNEC008-TD
NMC006-DPMC008-TDNEC006-DPEC008-TD
PMC006-DNMC008-RDPEC006-DNEC008-RD
NMC006-TDPMC008-RDNEC006-TDPEC008-RD
OTL Report No. 116-F-13-4

Summary

Product Series and Safety

Direct-Vent 500;600;800 Series Models

Critical Safety Information and Gas Leak Response

Essential safety warnings and procedures for handling gas leaks.

General Information and Installation

Installation Codes and Material Restrictions

Details installation compliance with codes and prohibits burning wood.

Appliance Operation and Care

Maintenance and Cleaning Procedures

Appliance and Vent System Inspection

Maintenance Schedule Details

Annual Maintenance Tasks

Glass Panel and Burner Adjustment

Front Glass Enclosure Panel Removal and Installation

Burner Flame Appearance and Air Shutter Adjustment

Guidance on achieving desired flame appearance and adjusting air shutters.

Log Placement and Air Shutter Settings

Factory Air Shutter Settings

Lighting Instructions - Millivolt Gas Valve

Millivolt Lighting Safety and Procedure

Step-by-step guide for safely lighting the millivolt pilot and burner.

Millivolt Shutdown Procedure

Lighting Instructions - Electronic Ignition

Electronic Ignition Safety and Procedure

Step-by-step guide for safely lighting the electronic ignition system.

Electronic Shutdown and Gas Off Procedure

Troubleshooting Millivolt Gas Controls

Millivolt Ignition and Pilot Issues

Addresses common problems like ignitor not sparking or pilot not staying lit.

Millivolt Burner and Outage Problems

Troubleshooting burner issues, no gas, and frequent pilot outages.

Troubleshooting Electronic Ignition System

Electronic Burner Ignition Failure

Diagnosing issues when the burner will not light or goes off prematurely.

Electronic Ignition System Flowchart

Visual guide for troubleshooting electronic ignition system faults.

Superior DT-600CEN Specifications

General

Model	DT-600CEN
Category	Indoor Fireplace
Type	Direct Vent Gas Fireplace
Warranty	Limited Lifetime Warranty
Ignition System	Electronic Ignition
Fuel Type	Natural Gas
Venting	Direct Vent
Finish	Black