Superior DT-800CMN - User Manual

1
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS
P/N 725,032M REV. H 11/2004
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
DIRECT-VENT
500/600/800 SERIES
MODELS
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
DR-500 MODEL SHOWN
sledoMtlovilliMsledoMcinortcelE
NMC005-DPMC006-TDNEC005-DPEC006-TD
PMC005-DNMC006-RDPEC005-DNEC006-RD
NMC005-TDPMC006-RDNEC005-TDPEC006-RD
PMC005-TDNMC008-DPEC005-TDNEC008-D
NMC005-RDPMC008-DNEC005-RDPEC008-D
PMC005-RDNMC008-TDPEC005-RDNEC008-TD
NMC006-DPMC008-TDNEC006-DPEC008-TD
PMC006-DNMC008-RDPEC006-DNEC008-RD
NMC006-TDPMC008-RDNEC006-TDPEC008-RD
OTL Report No. 116-F-13-4

Summary

GENERAL INFORMATION

OPERATION AND CARE OF YOUR APPLIANCE

Glass Cleaning and Maintenance Guidelines

General Appliance Maintenance Advice

Essential maintenance advice, including annual inspections and keeping control compartments clean.

Maintenance Schedule and Tasks

Annual Maintenance Tasks

Tasks to perform annually before the burning season, including inspections and cleaning of key components.

Periodic Maintenance Tasks

Front Glass Enclosure Panel and Burner Adjustments

Glass Panel Removal and Installation

Burner Flame Appearance and Sooting

Air Shutter Adjustment Procedure

Log Placement Guide

Ceramic Fiber Log and Twig Positioning

Embers, Stone, and Appliance Checkout Procedures

Glowing Embers and Volcanic Stone Placement

Millivolt Appliance Operational Checkout

Electronic Appliance Operational Checkout

LIGHTING INSTRUCTIONS - MILLIVOLT GAS VALVE

Millivolt Lighting Safety Precautions

Critical safety warnings and gas leak detection procedures before lighting the millivolt appliance.

Millivolt Pilot and Burner Lighting Steps

Step-by-step guide for safely lighting the pilot and main burner on millivolt systems.

LIGHTING INSTRUCTIONS - ELECTRONIC

Electronic Lighting Safety Precautions

Critical safety warnings and gas leak detection procedures before lighting electronic ignition systems.

Electronic Pilot and Burner Lighting Steps

Step-by-step instructions for safely lighting the appliance with an electronic ignition system.

TROUBLESHOOTING THE MILLIVOLT GAS CONTROL SYSTEM

Millivolt Ignition and Pilot Issues

Lists common ignition and pilot problems with their possible causes for millivolt systems.

Millivolt System Corrective Actions

Provides corrective actions for identified millivolt system troubleshooting issues.

TROUBLESHOOTING THE ELECTRONIC IGNITION SYSTEM

Electronic Ignition and Burner Problems

Identifies common electronic ignition and burner operation issues and their potential causes.

Electronic Ignition Troubleshooting Flowchart

A visual guide for diagnosing and resolving electronic ignition system issues step-by-step.

REPLACEMENT PARTS LIST

Main Fireplace Assembly Parts

Gas Controls Parts (Millivolt & Electronic)

Superior DT-800CMN Specifications

General

Brand	Superior
Model	DT-800CMN
Category	Indoor Fireplace
Language	English