Superior DT-500CMP - User Manual

1
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS
P/N 725,032M REV. H 11/2004
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
DIRECT-VENT
500/600/800 SERIES
MODELS
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
DR-500 MODEL SHOWN
sledoMtlovilliMsledoMcinortcelE
NMC005-DPMC006-TDNEC005-DPEC006-TD
PMC005-DNMC006-RDPEC005-DNEC006-RD
NMC005-TDPMC006-RDNEC005-TDPEC006-RD
PMC005-TDNMC008-DPEC005-TDNEC008-D
NMC005-RDPMC008-DNEC005-RDPEC008-D
PMC005-RDNMC008-TDPEC005-RDNEC008-TD
NMC006-DPMC008-TDNEC006-DPEC008-TD
PMC006-DNMC008-RDPEC006-DNEC008-RD
NMC006-TDPMC008-RDNEC006-TDPEC008-RD
OTL Report No. 116-F-13-4

Summary

Homeowners Care and Operation Instructions

Critical Safety Warnings and Gas Leak Procedures

Essential safety precautions, warnings, and steps to take if a gas leak is detected.

Appliance Operation and Care

Maintenance Schedule

Panel and Burner Adjustments

Burner Flame Appearance and Sooting

Flame Adjustment Procedure

Installation and Support Information

Warranty and Replacement Parts Guidance

Millivolt Lighting Instructions

Millivolt Safety Precautions Before Lighting

Crucial safety warnings and procedures to follow prior to lighting the millivolt pilot.

Millivolt Pilot Lighting and Operation

Step-by-step guide for lighting the pilot and operating the millivolt fireplace.

Millivolt Appliance Shutdown Procedures

Instructions for safely shutting down the millivolt fireplace.

Electronic Lighting Instructions

Electronic Safety Precautions Before Lighting

Crucial safety warnings and procedures to follow prior to lighting the electronic ignition.

Electronic Ignition and Operation Steps

Step-by-step guide for igniting the pilot and operating the electronic fireplace.

Electronic Appliance Shutdown Procedures

Instructions for safely shutting down the electronic fireplace.

Troubleshooting Millivolt Gas Control System

Millivolt Ignitor and Pilot Issues

Common problems with spark ignitors and pilot lights in millivolt systems.

Millivolt Burner and Pilot Outage Problems

Troubleshooting burner issues and frequent pilot/burner outages in millivolt systems.

Troubleshooting Electronic Ignition System

Electronic System Burner Ignition Faults

Diagnosing and resolving issues where the electronic burner fails to ignite.

Electronic System Burner Shutdown Causes

Identifying reasons for the electronic burner shutting off unexpectedly.

Replacement Parts List

Millivolt and Electronic Gas Control Parts

Superior DT-500CMP Specifications

General

Brand	Superior
Model	DT-500CMP
Category	Indoor Fireplace
Language	English