TECNICOMAR MINIMAR PLUS - Page 4

Instructions for the installation, use and maintenance of Tecnicomar watermaker
1-4
7.4 Membrane flushing with FL/411A and FL/412B chemicals .......................................................................... 7-28
7.5 General maintenance plan ............................................................................................................................. 7-29
7.5.1 Prefiltering circuit .................................................................................................................................. 7-29
7.5.2 Pressurizing circuit ................................................................................................................................ 7-29
7.5.3 Controls and produced water circuits ..................................................................................................... 7-29
7.6 Maintenance kit.............................................................................................................................................. 7-29
8 Common problems and troubleshooting ........................................................................................................... 8-31
8.1 First start-up .................................................................................................................................................. 8-31
8.2 Start-up after the replacement of filter cartridges ......................................................................................... 8-31
8.3 Low pressure failure ...................................................................................................................................... 8-31
8.4 Low pressure failure during normal operation .............................................................................................. 8-31
8.5 Operation with vessel in navigation, rough sea and LOW PRESSURE alarm on ......................................... 8-31
8.6 Normal operation of the watermaker and overload failure shutdown ........................................................... 8-32
8.7 UNSAFE warning message during normal operation ................................................................................... 8-32
8.8 The watermaker runs normally but the produced water does not reach the tanks ........................................ 8-32
9 Technical characteristics and spare parts ......................................................................................................... 9-33
9.1 Electrophysical characteristics ...................................................................................................................... 9-33
9.2 A typical analysis of produced water ............................................................................................................. 9-33
9.3 Spare part list ................................................................................................................................................ 9-34
9.3.1 High pressure pump ............................................................................................................................... 9-34
9.3.2 Other spare parts .................................................................................................................................... 9-34
9.4 Warranty for Tecnicomar equipments ........................................................................................................... 9-41
Annexes
DRAWINGS
Drawing 1 FLOW DIAGRAM
Drawing 2 CLEANING/STORAGE
Drawing 3 WIRING DIAGRAM
Drawing 4 AUTOMATIC PRESSURE REGULATOR
Drawing 5 ELECTR. CONNECTIONS
Drawing 6 AUTOMATIC FLUSHING SYSTEM
Drawing 7 PRESSURE VESSEL
 HIGH PRESSURE PUMP (Parts list – exploded view)
 LOW PRESSURE PUMP (Parts list – exploded view)
 Test certificate