rev 3/91 5 - 1 09-367
SERVICE section 5
SERVICE CHART
DAILY
50 HOUR
100 HOUR
250 HOUR
Read safety decals. X
Check fuel level. X
Check engine oil level. X
Check transaxle oil level. X
Check air cleaner. X
Check coolant level (Kubota). X
Visual inspection of:
Bolts and fittings for signs of loosening. X
Accumulation of dirt or foreign matter around engine restricting engine
cooling.
X
Oil leaks or hydraulic hoses, belts, electrical wiring, showing signs of wear. X
Tires for low pressure or signs of abnormal wear. X
Change engine oil and filter:
LINAMAR: Initial change at 25 hours and 50 hours thereafter.
KOHLER: Initial change at 25 hours and 100 hours thereafter.
KUBOTA: Initial change at 35 hours and 100 hours thereafter.
X
X
X
Check air cleaner:
Clean or replace. XXXX
Check battery water level:
If battery is serviceable, fill to cover the plates 1/4". X X X
Transaxles:
Check transaxle oil level. XXXX
Use only Steiner Trans-Hydraulic Oil or Texas Refinery Corp. 6440 Universal
Torque Fluid. Do not use automatic transmission fluid or motor oil.
Initial hydraulic filter change 25 hours.
Initial hydraulic oil and filter change 50 hours X
Change hydraulic oil and filter every 250 hours or annually
(whichever occurs first) X
Replace hydraulic oil and filter every 250 hours or at the first sign of any
abnormal hydraulic function.
X
Fuel System:
Check or replace filter. X
Lubrication:
Grease center pivot, PTO idler arm, and (drive shaft on Linamar & Kohler). X
Check Tire Pressure:
Air Pressure-5to8lbs. -- (Duals - 3 to 4 lbs. )
Outside duals should have no more than 50% of the inner tire pressure.
X
Storage:
Drain fuel tank. X
Maintain proper tire pressure. X
To Next Page
Loading...
Need help?
General
