INSPECTION AND MAINTENANCE 45
10
ENOM00093-A
Fuel filters and fuel tank cleaning
ENOW00093-B
Gasoline and its vapors are very flammable
and can be explosive.
Keep out of reach of children.
z Avoid repeated or prolonged contact with
skin or breathing of vapor.
z Do not start this procedure while engine
is operating or hot even after stopping it.
z Place fuel filter away from every source of
ignition such as sparks or open flames.
z Wipe off gasoline well immediately if
spilled and dispose of it in accordance
with local fire prevention and environ-
ment protection regulations.
z Install fuel filter with all related parts in
place, or fuel leak could occur, leading to
catching fire or explosion.
z Check fuel system regularly for leakage.
z Contact authorized dealer for fuel system
services. Services by unqualified person
could lead to engine damage.
Fuel filters are provided inside the fuel
tank and engine.
ENOM01405-0
Fuel filter (for fuel tank)
Water or dirt in the fuel tank will cause
engine performance problems.
Check and clean the tank at specified
times or after the outboard motor has
been stored for a long period of time
(over three months).
integral tank type
1. Drain all fuel from the fuel tank.
2. Remove the fuel cock from the fuel
tank and clean the fuel filter. Replace
it if necessary.
1. Fuel tank
2. Fuel filter
3. Fuel cock
ENOM00098-A
Gear oil replacement
ENOW00094-0
z Be sure that outboard motor is secured to
transom or service stand, or accidental
drop or fall of outboard motor could lead
to severe personal injury.
z Be sure to lock outboard motor if it is
tilted up, or accidental fall of outboard
motor could lead to severe personal
injury.
z Do not go under outboard motor tilted up
and locked, or accidental fall of outboard
motor could lead to severe personal
injury.
ENON00934-0
Note
Please dispose of used oil in a manner that
is compatible with the environment.
We suggest you take it in a sealed con-
tainer to your local service station for rec-
lamation. Do not throw it in the trash, pour
it on the ground or down a drain.
1. Tilt down the outboard motor.
WARNING
WARNING
To Next Page
