Toro 07211 - Maintenance; Recommended Maintenance Schedule

42
Maintenance
Recommended Maintenance Schedule
Maintenance Service
Interval
Maintenance Procedure
After first 10 hours
• Check cable adjustments
• Torque wheel lug nuts
• Replace transaxle filter
After first 50 hours • Replace the engine oil and filter.
Every 50 hours
• Check the battery fluid level.
• Check the battery cable connections.
• Service the air cleaner.
Every 100 hours
• Lubricate all grease fittings
• Inspect condition and wear of tires
• Check front differential oil level (4WD)
• Replace engine oil and filter
• Inspect cooling system hoses
• Check governor oil level
Every 200 hours
• Check cable adjustments
• Check alternator, governor and fan belts
• Change air cleaner filter
• Check front axle CV boot joint (4WD)
• Check engine RPM (idle and full throttle)
• Torque wheel lug nuts
Every 400 hours
• Check front wheel alignment
• Inspect service and parking brakes
• Inspect fuel lines
• Replace fuel filter
• Adjust valves
• Replace spark plugs and check timing
Every 800 hours
• Replace transaxle filter
• Change transaxle oil
• Clean transaxle strainer
• Pack front wheel bearings
• Change front differential oil (4WD)
Every 1200 hours or 2
years (whichever
occurs first)
• Replace all interlock switches
• Coolant System – flush/replace fluid
• Change brake fluid
Every 2000 hours or 2
years (whichever
occurs first)
• Replace engine timing belt
1
immediately after every washing, regardless of the interval listed
Important Refer to your engine operator’s manual for additional maintenance procedures.