Toro 07211 - Safety and Instruction Decals

60 pages

To Next Page

To Previous Page

Safety and Instruction Decals

Safety decals and instructions are easily visible to the operator and are located near any area

of potential danger. Replace any decal that is damaged or lost.

87-8520

Model 07211 & 07212

87-9880

Model 07218

Main Page

Table of Contents2
Introduction3
Safety3
Safe Operating Practices4
Supervisor's Responsibilities4
Before Operating4
While Operating5
Maintenance6
Sound Pressure Level6
Vibration Level6
Safety and Instruction Decals7
Specifications15
General Specifications15
Dimensions16
Setup17
Install Rear Fenders18
Install Wheels18
Install Steering Wheel18
Install Front Fenders19
Install ROPS19
Activate and Charge Battery19
Full Bed Removal21
Re-Install Full Bed21
Before Operating23
Check Crankcase Oil23
Fill Fuel Tank24
Check Cooling System24
Check Transaxle / Hydraulic Fluid25
Check Front Differential Oil25
Check Torque of Wheel Nuts26
Check Tire Pressure26
Check Brake Fluid27
Operation28
Controls28
Pre-Starting Checks31
Starting Engine31
Driving Vehicle31
Stopping Vehicle32
Stopping Engine32
New Vehicle Break-In32
Check Interlock System32
Operating Characteristics32
Passengers33
Speed33
Turning33
Braking33
Tipovers34
Hills35
Loading and Dumping35
Using the Differential Lock36
Four Wheel Drive36
Transporting Vehicle37
Towing Vehicle37
Trailer Towing37
Remote Hydraulic Control38
Maintenance40
Service Interval Chart40
Greasing Bearings and Bushings40
Maintenance42
Recommended Maintenance Schedule42
Daily Maintenance Checklist43
Heavy Duty Operation44
Using Bed Safety Support44
Jacking Vehicle45
General Air Cleaner Maintenance Practices45
Servicing Air Cleaner45
Changing Engine Oil and Filter46
Fuel System46
Removing Debris from Engine Cooling System47
Changing Engine Coolant47
Adjusting Belts48
Adjusting Accelerator Pedal49
Changing Transaxle / Hydraulic Fluid49
Replacing Hydraulic Filter50
Change Front Differential Oil50
Cleaning Hydraulic Strainer50
Replacing Spark Plugs51
Adjusting Brake Pedal51
Adjusting Clutch Pedal52
Adjusting Parking Brake52
Adjusting Shift Cables53
Adjusting High-Low Cable53
Adjusting Differential Lock Cable53
Inspect Brakes53
Inspect Tires53
Front Wheel Toe-In53
Inspect Constant Velocity Boot54
Emergency Box Raising54
Fuses54
Jump Starting Procedure54
Battery Storage55
Battery Care55
Hydraulic Schematic56
Hydraulic Schematic57
Electrical Schematic58
Electrical Schematic59
The Toro General Commercial Products Warranty60

Toro 07211 - Safety and Instruction Decals

Table of Contents

Related product manuals