Toro 20363 Service Manual

134 pages

To Next Page

To Next Page

Page #1 background image

Loading...

Page #1 background image

FormNo.3429-828RevA

60vWPMServiceManual

Published:December2019

©2019—TheToro®Company

8111LyndaleAvenueSouth

Bloomington,MN55420

OriginalInstructions(EN)

Contactusatwww.Toro.com.

AllRightsReserved

Table of Contents

Table of Contents5
Section 125
- Chapter 4 :Powerheadassembly26
  - General Information26
  - Service and Repairs27
    - 20363 With Personal Pace 22 Inch Recycler Power Head Assembly Replacement29
    - 20361 22 Inch Recycler Power Head Assembly Replacement35
Section 237
- Chapter 5 :Controls38
  - General Information38
  - Service and Repairs39
    - Starter Switch Replacement41
    - Safety Bail Switch Replacement44
Section 347
- Chapter 6 :Chargerandbattery48
  - General Information48
  - Service and Repairs49
    - Battery50
    - Charger50
Section 451
Section 5101
- Default Chapter102
- Chapter 10 :Motor105

Other manuals for Toro 20363

Operator's Manual24 pages

Questions and Answers:

Y
ybarreraAug 16, 2025
How to troubleshoot a Toro Lawn Mower that won't start?
- R
  Ricky MarquezAug 16, 2025
  If your Toro Lawn Mower doesn't start, there are several potential causes: 1. The battery might not be fully installed. Remove and replace the battery, ensuring it's fully installed and latched. 2. The battery pack may not be charged. Remove the battery pack and charge it. 3. The battery pack could be damaged, requiring a replacement. 4. There may be another electrical problem with the machine. In this case, contact an Authorized Service Dealer.
J
Jeffrey DavisAug 19, 2025
Why is my Toro 20363 Lawn Mower beeping?
- B
  Brian GriffinAug 20, 2025
  A beeping sound from your Toro Lawn Mower can indicate several issues: 1. The battery pack may not be charged. Remove it and charge it. 2. The machine might be in an unsafe position. Ensure it's not at an extreme angle during operation. 3. The machine could be overloaded. Try cutting the grass at a higher setting or walking slower. 4. There may be another electrical problem with the machine. Attempt the other troubleshooting actions, and if the alarm still sounds, contact an Authorized Service Dealer.
M
Michael LoveAug 22, 2025
What to do if my Toro 20363 Lawn Mower doesn't have full power?
- W
  watsonluisAug 22, 2025
  If your Toro Lawn Mower isn't reaching full power, consider these possibilities: 1. The battery pack charge could be too low. Remove it and fully charge it. 2. The air vents might be blocked. Clean the air vents to ensure proper airflow.
R
Regina HebertAug 26, 2025
Why does my Toro Lawn Mower stop running?
- G
  garrettwilliamsAug 26, 2025
  If your Toro Lawn Mower doesn't run continuously, it could be due to: 1. Moisture on the battery pack leads. Allow the battery pack to dry or wipe it dry. 2. The battery not being fully installed. Remove and replace the battery, ensuring it is fully installed and latched.
B
Brian StewartAug 28, 2025
Why is my Toro 20363 cutting unevenly?
- J
  joannarodriguezAug 28, 2025
  If your Toro Lawn Mower is cutting unevenly, it could be due to: 1. A dull blade. Have the blade sharpened or replaced. 2. A damaged cutting deck. Contact an Authorized Service Dealer.
E
Erica ReedAug 31, 2025
What to do if Toro 20363 battery charger is not working?
- A
  Andrew WilliamsAug 31, 2025
  If your Toro Lawn Mower battery charger isn't working, check these: 1. The charger might be outside the correct temperature range. Unplug it and move it to a dry place where the temperature is between 5°C (41°F) and 40°C (104°F). 2. The outlet may not have power. Contact a licensed electrician to repair the outlet.
S
Samantha Mcmahon MDSep 3, 2025
Why is the LED indicator light blinking red on my Toro 20363 battery charger?
- D
  Dakota RhodesSep 3, 2025
  A blinking red LED on your Toro Lawn Mower battery charger can indicate: 1. An error in communication between the battery pack and charger. Remove the battery, unplug the charger for 10 seconds, then plug it back in and replace the battery. Repeat if necessary. If it continues, dispose of the battery at a recycling facility. 2. The battery pack is weak. Dispose of the battery pack at a battery recycling facility.
F
Frank HowardSep 6, 2025
Why is the LED indicator light on my Toro Lawn Mower battery charger red?
- A
  Anne ReyesSep 7, 2025
  If the LED indicator light on your Toro Lawn Mower battery charger is red, it could be because the charger and/or battery pack is outside the appropriate temperature range. Unplug the charger and move both to a dry place where the temperature is between 5°C (41°F) and 40°C (104°F).
D
Debra BeardSep 9, 2025
Why is my Toro 20363 Lawn Mower vibrating so much?
- J
  Jerome BatesSep 10, 2025
  If your Toro Lawn Mower is vibrating, the blade might be bent or damaged. Inspect the blade and replace it if necessary.

Toro 20363 Specifications

General

Brand	Toro
Model	20363
Category	Lawn Mower
Language	English

Related product manuals

Preview: Toro 20360

Preview: Toro e-cycler 20360

Toro e-cycler 20360

Preview: Toro Recycler 20363

Toro Recycler 20363

Preview: Toro 20373

Preview: Toro 20339

Preview: Toro 20371

Preview: Toro 20340

Preview: Toro 20377

Preview: Toro 20332

Preview: Toro Recyler 20333

Toro Recyler 20333