Toro Reelmaster 335-D - Page 95

___________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
___________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
Traction Response Is Sluggish
Cause Correction
Brakes dragging. Inspect brakes and adjust or repair if necessary.
Charge pressure low - TEST NO. 8. Inspect charge relief valve and adjust or repair if nec-
NOTE: Counterbalance pressure will also be essary.
affected.
Inspect auxiliary pump and repair or replace if
necessary NOTE: Steering and lift will also be af-
fected if auxiliary pump is damaged.
Pump or motor damaged. Inspect and repair or replace traction pump or motor
if ne
cessary.
Machine Will Not Travel In Either Direction
Cause Correction
Front axle shift lever in neutral (middle) position. Move shift lever to engage transmission.
Damaged front axle or rear 4wd axle. Repair axle.
Brakes engaged. Inspect brakes and adjust or repair if necessary.
Hydraulic oil level too low. Fill to proper level.
Control linkage damaged or out of adjustment. Repair control linkage.
Charge pressure low - TEST NO. 8. Inspect charge relief valve and adjust or repair if nec-
NOTE: Counterbalance pressure will also be essary.
affected.
Inspect auxiliary pump and repair or replace if neces-
sary NOTE: Steering and lift will also be affected if
auxiliary pump is damaged.
Traction pressure too low - TEST NO. 1. Inspect traction pump check/relief valves and repair
o
r replace if necessary.
Check for damaged pump or motor(s) and repair or
replace if necessary.
Reelmaster
®
335-D Page 4 - 15 Troubleshooting