Toro TimeCutter SW 4200 - User Manual

Toro TimeCutter SW 4200

60 pages

To Next Page

To Next Page

Loading...

FormNo.3393-656RevA

TimeCutter

®

SW4200orSW5000

RidingMower

ModelNo.74675—SerialNo.315000001andUp

ModelNo.74680—SerialNo.315000001andUp

g027698

Registeratwww.Toro.com.

OriginalInstructions(EN)

*3393-656*A

Table of Contents

Questions and Answers:

K
Keith DominguezSep 3, 2025
Why is my Toro TimeCutter SW 4200 Lawn Mower cutting height uneven?
- J
  Jonathan GomezSep 3, 2025
  Uneven cutting height with your Toro Lawn Mower can be due to several reasons. The blade(s) might not be sharp, so sharpen them. A cutting blade(s) may be bent, so install a new cutting blade(s). Ensure the mower is level from side-to-side and front-to-rear. Check that the anti-scalp wheel is set correctly and adjust its height if needed. A dirty mower underside can also cause this, so clean it. Finally, verify that the tire pressure is correct and adjust it accordingly. If a blade spindle is bent, it is recommended to contact an Authorized Service Dealer.
R
rsmithSep 16, 2025
What to do if Toro TimeCutter SW 4200 engine overheats?
- E
  Edward GomezSep 16, 2025
  If your Toro Lawn Mower engine is overheating, there are several possible causes. First, the engine load may be excessive, so reduce the ground speed. Second, check the oil level in the crankcase and add oil if it is low. Third, inspect the cooling fins and air passages under the engine blower housing for obstructions and remove them. Fourth, the air cleaner may be dirty, so clean or replace the air-cleaner element.
R
Ryan HubbardAug 31, 2025
Why are the blades not rotating on my Toro TimeCutter SW 4200 Lawn Mower?
- B
  Breanna MendozaAug 31, 2025
  If the blades on your Toro Lawn Mower aren't rotating, check the following: 1. The drive belt may be worn, loose, or broken, so install a new one. 2. If the drive belt is off the pulley, install it and check the adjusting shafts and belt guides for the correct position. 3. The mower belt may be worn, loose, or broken, so install a new mower belt.
B
Bradley JonesSep 18, 2025
Why Toro Lawn Mower fuel tank collapses?
- J
  Jordan Cook PhDSep 18, 2025
  If the fuel tank on your Toro Lawn Mower is collapsing, or the machine frequently runs out of fuel, it could be due to a clogged air-cleaner paper element. Clean the paper element to resolve this issue.
W
William ReillySep 18, 2025
How to fix abnormal vibration in Toro TimeCutter SW 4200?
- J
  Joe JohnsonSep 18, 2025
  To address abnormal vibration in your Toro Lawn Mower, begin by checking if the engine-mounting bolts are loose and tighten them. Also, inspect the engine pulley, idler pulley, or blade pulley for looseness and tighten the appropriate pulley. Ensure that a blade-mounting bolt is tightened. If the cutting blades are bent or unbalanced, install new cutting blades.
B
Benjamin GeorgeSep 23, 2025
Why is the fuel tank collapsing on my Toro TimeCutter SW 4200 Lawn Mower or the machine frequently running out of fuel?
- J
  Joseph MillerSep 23, 2025
  If your fuel tank is collapsing or the machine frequently runs out of fuel, the air-cleaner paper element might be clogged. Clean the paper element to resolve this issue.
L
Linda BryantAug 28, 2025
Why is the cutting height uneven on my Toro TimeCutter SW 4200?
- J
  Joseph Rivera Jr.Aug 28, 2025
  If the cutting height of your Toro Lawn Mower is uneven, ensure the blade(s) is sharp and sharpen it if needed. If a cutting blade(s) is bent, install a new one. Level the mower from side-to-side and front-to-rear. Adjust the anti-scalp wheel height if it is not set correctly. Clean the underside of the mower if it is dirty. Adjust the tire pressure to the correct level. If a blade spindle is bent, contact an Authorized Service Dealer.
D
dwilliamsAug 27, 2025
How to fix Toro TimeCutter SW 4200 when the starter does not crank?
- R
  Ronald RobinsonAug 27, 2025
  If the starter on your Toro Lawn Mower does not crank, make sure the blade-control switch is disengaged. If not, move the blade-control switch to Disengaged. Check the battery and charge it if it's dead. Inspect the electrical connections for corrosion or looseness and ensure they have good contact. Also, check the fuse and replace it if it's blown. If a relay or switch is damaged, contact an Authorized Service Dealer.
R
robertgrossAug 26, 2025
What to do if my Toro TimeCutter SW 4200 engine won't start?
- J
  Joy RodgersAug 27, 2025
  If your Toro Lawn Mower engine does not start, starts hard, or fails to keep running, start by checking if the fuel tank is empty and fill it if necessary. Ensure the choke is on by moving the choke lever to the On position. Inspect the air cleaner for dirt and clean or replace the element. Verify that the spark plug wire(s) is securely installed on the spark plug. Check the spark plug(s) for pitting, fouling, or incorrect gap and replace if needed. If there is dirt in the fuel filter, replace it. If there is incorrect fuel in the fuel tank, drain the tank and replace the fuel with the proper type. Finally, check the oil level in the crankcase and add oil if it is low. If you suspect dirt, water, or stale fuel is in fuel system, contact an Authorized Service Dealer.
B
bsandovalAug 25, 2025
Why Toro TimeCutter SW 4200 engine does not start?
- I
  inelsonAug 26, 2025
  Your Toro Lawn Mower engine might not be starting due to several reasons. Check if the fuel tank is empty and fill it if needed. Ensure the choke is on. A dirty air cleaner can also be the culprit, so clean or replace it. Inspect the spark plug wire(s) and ensure they are properly connected. The spark plug(s) might be pitted, fouled, or have an incorrect gap, in which case you should install a new one with the correct gap. Also, check for dirt in the fuel filter and replace it if necessary. Low oil level in the crankcase may also cause this issue, so add oil if needed. Finally, ensure that the fuel tank has the proper type of fuel.

Toro TimeCutter SW 4200 Specifications

General

Transmission	Hydrostatic
Cutting Width	42 inches
Seat	High-back
Cutting Height	1.5 - 4.5 inches
Warranty	3-year limited

Summary

Safety and Operation

Safe Operating Practices

Guidelines for safe operation, training, and preparation.

Toro Mower Safety

Specific safety information related to Toro mower products.

Slope Operation

Precautions and techniques for operating on slopes safely.

Safety and Instructional Decals

Identification and explanation of safety decals on the machine.

Product Features and Controls

Product Overview

Detailed identification of mower parts and components.

Controls

Explanation of ignition, choke, throttle, and other operating controls.

Maintenance

Recommended Maintenance Schedule(s)

Table outlining maintenance tasks based on service intervals.

Premaintenance Procedures

Steps to take before performing maintenance.

Lubrication

Instructions for greasing the machine's bearings.

Engine Maintenance

Servicing the air cleaner, oil, spark plug, and filters.

Fuel System Maintenance

Steps for replacing the in-line fuel filter.

Electrical System Maintenance

Procedures for charging the battery and servicing fuses.

Drive System Maintenance

Checking tire pressure and releasing the electric brake.

Mower Maintenance

Servicing cutting blades, leveling deck, and belt maintenance.

Cleaning

How to clean the front and underside of the machine.

Storage

Procedures for preparing the machine for storage.

Troubleshooting and Schematics

Troubleshooting

Solutions for common operational problems and issues.

Schematics

Electrical diagram of the machine's wiring system.

Support and Warranty

International Distributor List

Contact information for Toro distributors worldwide.

Toro Warranty Information

Details on product warranty coverage and owner responsibilities.

Related product manuals

Preview: Toro TimeCutter SW 5000

Toro TimeCutter SW 5000

Toro TimeCutter SW 3200

Preview: Toro TimeCutter SW Series

Toro TimeCutter SW Series

Preview: Toro TimeCutter SS 4200

Toro TimeCutter SS 4200

Preview: Toro TimeCutter SS 4200 74720

Toro TimeCutter SS 4200 74720

Preview: Toro TimeCutter 4200

Toro TimeCutter 4200

Toro TimeCutter MX 4200

Preview: Toro TimeCutter SW4200

Toro TimeCutter SW4200

Toro TimeCutter SS 4235

Preview: Toro TimeCutter SS 4225

Toro TimeCutter SS 4225

Preview: Toro TimeCutter SS 5060

Toro TimeCutter SS 5060

Preview: Toro TimeCutter SS 5000

Toro TimeCutter SS 5000