Trane NO Series User Manual

14 SEER / 81% AFUE
Single Package Gas Heating / Electric Cooling
4YCL Ultra Low NOx Series
INSTALLATION INSTRUCTIONS
WARNING AVERTISSEMENT
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property
damage.
RISQUE D’INCENDIE OU D’EXPLOSION
Si les consignes de sécurité ne sont pas suivies à la lettre,
cela peut entraîner la mort, de graves blessures ou des
dommages matériels.
– Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a
neighbors phone. Follow the gas suppliers
instructions.
• If you cannot reach your gas supplier, call the
fire department.
– Installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
– Ne pas entreposer ni utiliser de l’essence ni d’autres vapeurs
ou liquides inflammables dans le voisinage de cet appareil,
ni de tout autre appareil.
QUE FAIRE SI UNE ODEUR DE GAZ EST DÉTECTÉE
• Ne mettre en marche aucun appareil.
• Ne toucher aucun interrupteur électrique; ne pas utiliser
de téléphone dans le bâtiment.
• Quitter le bâtiment immédiatement.
• Appeler immédiatement le fournisseur de gaz en utilisant le
téléphone d’un voisin. Suivre les instructions du fournisseur
de gaz.
• Si le fournisseur de gaz n’est pas accessible, appeler le
service d’incendie.
– L’installation et l’entretien doivent être effectués par un
installateur ou une entreprise d’entretien qualifié, ou le
fournisseur de gaz.
DO NOT DESTROY THIS MANUAL. READ ALL INSTRUCTIONS IN THIS MANUAL AND KEEP IN A SAFE PLACE FOR FUTURE REFERENCE.
NE PAS DÉTRUIRE. LIRE TOUTES LES INSTRUCTIONS DONNÉE DANS LE MANUEL ET CONSERVER EN UN LIEU SÛR POUR RÉFÉRENCE ULTÉRIEURE.
This product complies with SJVAPCD 4905 and SCAQMD 1111 with NOx levels below 14ng/J when operated on natural gas.

Trane NO Series Specifications

General

Brand	Trane
Model	NO Series
Category	Heating System
Language	English

Summary

Important Safety Information

Electrical Safety Warnings

Warnings related to electrical shock, fire, and explosion hazards during installation and servicing.

Fire and Explosion Hazards

Precautions against storing or using flammable materials near the unit to prevent fire and explosion.

General Installation Safety

Critical warnings for unqualified individuals to avoid hazardous situations during installation.

Combustion Air and Venting Requirements

Carbon Monoxide Poisoning Hazard

Critical safety steps for operating appliances connected to the venting system to prevent CO poisoning.

Vent Termination Requirements

Specifies location, clearance, and installation requirements for the vent termination for safe operation.

Electrical Wiring

Electrical Installation Compliance

Gas Supply and Piping

Gas Piping and Supply Requirements

Outlines compliance with codes, shut-off valve requirements, pressure settings, and leak checks.

Start Up and Adjustments

Pre-Start Checks and Initial Operation

Covers pre-start checklist and step-by-step procedures for air circulation, cooling, and heating startup.

Performance Adjustments

Procedures for verifying and adjusting temperature rise, firing rate, and burner settings for optimal performance.

Safety Control Verification

Equipment Maintenance

Maintenance Safety and Filter Care

Critical safety precautions for maintenance and guidelines for filter and coil cleaning.

Troubleshooting

Cooling Mode Operational Checks

Diagnostic Codes and Error Indicators

Operating Instructions

Pre-Operation Safety Checks

Essential safety steps and checks before operating the appliance, including smelling for gas.

Appliance Start-Up Procedure

Wiring Diagram and Electrical Data

Unit Wiring Diagram

Refrigerant Charging

Refrigerant Handling Safety

Crucial safety warnings and precautions for handling R-410A refrigerant during installation or repair.

Cooling System Charging Charts

Installation Checklist

Site and System Readiness Checks

Electrical System and Installer Duties