210OPTRS 6 2008
ITEM DESCRIPTION RECOMMENDED SERVICE
1. Blower Bearings Grease once a week or every 25 hours of operation.
2. Blower Power Band Re-tension after initial 10 hours; then check every 150 hours.
3. Blower Wheel Inspect monthly for wear. DO NOT REACH INTO
BLOWER HOUSING FOR ANY REASON!
4. Gutter Broom / Wafer Check DAILY for string, cassette tape, etc on motor shaft.
Re-tension spring when new wafers are installed.
5. Hydraulic Reservoir Drain oil after initial 100 hours; then every 1000
hours or once a year. Check oil level DAILY.
6. Hydraulic Oil Filter Change every 100 hours.
7. Aux. Engine Air Cleaner Replace when restriction indicator shows red.
8. Auxiliary Engine Change oil every 100 hours, for additional service
refer to engine manual. Check oil level DAILY.
9. Console Fuse Panel Always replace fuse with identical amp rating.
10. Both Engine Radiators Check DAILY. CAUTION - Check only when cold.
11. Truck Air Cleaner Service every 25 hours or when restriction gauge
indicates.
12. Transmission Change oil & filter every 15,000 miles or once a year.
13. Water Tank Drain tank DAILY.
14. Centrifugal Separator Wash out DAILY! Cleanout door provided on engine
side.
15. Separator Seal Clean seal DAILY. Hopper must be airtight and fit
snuggly against seal when lowered.
16. Skimmer Hood Inspect DAILY! Skimmer hood must swing freely when
hopper is raised in order to clean itself of debris.
17. Hopper Screen Wash DAILY to prevent air blockage.
18. Hopper Wash out at end of each shift to prevent rusting.
19. Dump Door Seal Inspect DAILY; replace if damaged.
20. Hopper Pivot Hinge Grease every 25 hours of operation or once a week.
CAUTION: Hopper must be raised in order to grease
hinge. Always Install Pin in Lower Safety Strut!
21. Truck Tires Check DAILY for flats and correct air pressure.
22. Spring Tension Check skid plates weekly for wear; adjust spring
tension as required.
23. Pick-Up Head Curtains Inspect DAILY; replace when worn out .
24. Drag Link Inspect DAILY for condition
25. Truck Engine Change oil and filter every 100 hours or 3000 miles of
operation.
NEVER REACH INTO BLOWER HOUSING FOR ANY REASON!
To Next Page
Loading...