Need help?Do you have a question about the TYMCO DST-6 and is the answer not in the manual?
Pre-operation checks for the sweeper.
Steps to start the sweeper.
Specific startup for CNG models.
How to adjust the leaf pressure bleeder.
Steps to safely turn off the sweeper.
Specific shutdown for CNG models.
Daily cleaning tasks for the sweeper.
Guidelines for parking the sweeper.
List of inspection items for the sweeper.
List of performance and maintenance tasks.
General overview of operating the DST-6 sweeper.
Pre-operation checks before starting the DST-6.
Checks to perform while the sweeper is running.
How to operate in dustless mode.
How to operate in standard (wet) mode.
Steps for cleaning the sweeper hopper.
Cleaning specific sweeper components.
Information on cleaning and maintaining DST-6 filters.
Inspecting and maintaining hopper seals for airtightness.
Servicing and maintenance of the gutter broom.
Maintenance and service for the pick-up head.
Care and maintenance of the centrifugal separator.
Maintenance and replacement of DST-6 filters.
Procedure for cleaning the filter box.
Maintenance and service for the air compressor.
Procedures for dumping the hopper and cleaning it.
Service and maintenance of hopper components like seals and screens.
How to operate the blower assembly.
Recommended engine RPM settings for the blower.
Recommended speeds for various sweeping conditions.
Periodic servicing of the blower assembly.
Information on the hydraulic fluid reservoir.
Details about the hydraulic pumps.
Explanation of the hydraulic control valve assembly.
Specifics on the BAH hydraulic control valves.
Service procedures for control valves.
Warning about over-servicing air cleaner elements.
Steps to avoid dust contamination during service.
Information on replacing vacuator valves.
Adjusting gutter broom spring and tilt.
Procedure for replacing gutter broom bristles.
Servicing the gutter broom torque motor and shoulder plate.
How to operate the pick-up head.
Setting and adjusting the pick-up head skid plates and springs.
Daily inspection items for the pick-up head.
Daily service checks for the broom assist.
How to operate the dust control water system.
Service areas for the water system.
Procedures for winterizing the water system.
Purging water from the system.
To Next Page
General