USAutomatic PATRIOT Series - Default Chapter; Table of Contents

1
INTRODUCTION
Entrapment Device Requirements and Zones ............................................................................................2-3
Important Safety Instructions and Safety Installation Information .............................................................4-5
Patriot Parts Inventory .................................................................................................................................. 6
Patriot Hardware Inventory ............................................................................................................................7
Actuator Dimensions .....................................................................................................................................8
General Tool Requirements ........................................................................................................................... 8
PREPARATION AND OVERVIEW
Gate Qualications/Applications ....................................................................................................................9
Proper Gate Design .....................................................................................................................................10
INSTALLATION INSTRUCTIONS
1. Mounting Site Review ......................................................................................................................... 11
2. Determine Opening Method (pull to open or push to open) ................................................................12
3. Determine Horizontal Mounting Location ............................................................................................13
4. Determine Best Method for Actuator Mounting Brackets - Pull to Open .............................................14
Determine Best Method for Actuator Mounting Brackets - Push to Open ........................................... 15
Determine Best Method for Actuator Mounting Brackets - Columns ....................................................16
5. Mount Support Bracket .......................................................................................................................17
6. Installing Actuator Mounting Tube - Pull to Open ................................................................................18
Installing Actuator Mounting Tube - Push to Open ............................................................................... 19
7. Installing Linear Actuator to Actuator Mounting Bracket .......................................................................20
8. Install Gate Bracket to Linear Actuator .................................................................................................20
9. Install Gate Bracket to Gate .................................................................................................................21
10. Install Patriot Control Box / Control Box Dimensions ...................................................................21 - 22
11. Install Patriot Control Board ................................................................................................................22
12. Installing Receiver and Smart Charger / Charge Controller and Entrapment Siren ............................. 23
13. Install Linear Actuator Cable ................................................................................................................23
13a. Splicing Linear Actuator Cable Cable and Dual Gate Cable ................................................................. 24
14. Installing Monitored Entrapment Protection Devices ...........................................................................25
Monitored Photo Eye (Type B1) Installation ......................................................................................... 25
Monitored Contact Edge (Type B2) Installation ....................................................................................25
Constant Pressure (Type D) Installation ..............................................................................................25
15. Install Battery ........................................................................................................................................26
16. Install Charger / Charge Controller Power Source (AC or Solar) .................................................26 - 27
17. Connect Power Source to Smart Charger / Charge Controller ...........................................................28
18. Install Safety Signs ...............................................................................................................................28
19. Connect Linear Actuator Cable to Control Board ................................................................................ 28
20. Photo Eye Alignment ............................................................................................................................ 28
21. Operating Gate For The First Time .......................................................................................................29
22. Optional Soft Stop for Retract and Extend Position ............................................................................30
23. Gate Delay Feature .............................................................................................................................. 30
24. Making Retract and Extend Limit Adjustments ....................................................................................31
25. Sensitivity Adjustment and Entrapment Alarm .....................................................................................32
26. Verifying Inherent Entrapment Protection System (Type A) Operation ................................................32
26a. Verifying Monitored Entrapment Devices ............................................................................................. 33
27. Patriot Control Board Information ..................................................................................................34 - 37
28. Programming Transmitter and Receiver .............................................................................................38
PROGRAMMING WIRELESS KEYPAD ..................................................................................................39 - 41
PERIODIC SERVICE / EMERGENCY MANUAL RELEASE
..................................................... 44
ACCESSORIES ............................................................................................................................... 45 - 47
TROUBLESHOOTING .........................................................................................................48 - 63
APPENDIX
A. Photo Eye - Vehicular Protection Only ..............................................................................................64 - 65
B. Extending Charge Device Location..........................................................................................................66
C. Charge Controller ....................................................................................................................................67
WARRANTY
............................................................................................................................. 69
TABLE OF CONTENTS