VIAVAC CB4 - C 4 Inspection & Maintenance Report

MANUAL VIAVAC-CB4 / 4.1 ( Expert section ) Art. nr. 50504 EN (01-07-2017)
__________________________________________________________________________________________
6
___________________________________________________________________________________
VIAVAC vacuum lifting BV T. + 31 348 449 660 E. info@viavac.com I. www.viavac.com
C 4 Inspection & maintenance report
Machine nr. : . . . . . . . . Owner : . . . . . . . .
Type : . . . . . . . . Contact person : . . . . . . . .
___________________________________________________________________________________________________
APPROVED
Limited value A D M Y 3Y
1. Suction pads Type . . . . . . . O
Sealing profiles checked for cracks and wear. O O O O
Replace the sealing profile - - - O
Rubber back plate, cleaned and free from grease. O O O O
Rubber back plate cleaned with natural vinegar. - O O O
Replace the rubber backplate - - - O
2. Suction pads Type . . . . O
Sealing profiles checked for cracks and wear. O O O O
Replace the sealing profile - - - O
Rubber back plate, cleaned and free from grease. O O O O
Rubber back plate cleaned with natural vinegar. - O O O
Replace the rubber backplate - - - O
3. Suction pads Type . . . . O
Sealing profiles checked for cracks and wear. O O O O
Replace the sealing profile - - - O
Rubber back plate, cleaned and free from grease. O O O O
Rubber back plate cleaned with natural vinegar. - O O O
Replace the rubber backplate - - - O
Filter/water separator
Remove water and dirt from bowl O O O O
Clean filter in bowl - - O O
Water
Drain by opening valve (when used in rain) O O O O
Falling safety device for vertical wall panels O
Check for cracks and wear O O O O
Check mechanical condition and functioning O O O O
Falling safety device for horizontal wall and roof panels O
Check for cracks and wear O O O O
Check mechanical condition and functioning O O O O
Mechanical
Check lifting eye O O O O
Check securing device from handle “suction/aeration” O O O O
Check main and cross traverses for cracks. O O O O
Check rotation of main traverse. O O O O
Check locking device of main traverse. O O O O
Alarm
Acoustic alarm + illumination of red lamp at vacuum level < -0.60 bar (+/- 2%) 85db O O O O
Illumination of green lamp and switch off alarm at vacuum level of > -0.60 bar (+/- 2%) O O O O
____________________________________________________________________________________________________________________________
Continues on the next page (A = Available / D = Daily / M = Monthly / J = Yearly / 3 Yearly)