Initial Sta rt-up and Service
36
Service Schedule
Frequently - by owner
Check pressure gage for correct system (water) pres sure.
Check for water on floor from discharge pipe of the
pressure relief valve or any other pipe, pipe joint, valv e or
air vent.
Check for moisture, water, or appearance of rust on flue
gas pipes or their joints.
The area around the outside side wall vent terminal must be
inspected frequently when severe weather conditions
prevail, otherwise on a weekly basis to ensure that the v ent
terminal is not blocked by snow, ice or debris.
Ensure that nothing is obstructing the flow of combustion
ventilation air a nd no chemicals, garbage, gasoline,
chlorides, combustible materials, flammable v apors and
liquids are stored (not even temporarily) in the vicinity of
the boiler.
Periodically
Inspect low water cut-offs, including flushing of float t y pes
(if used).
Inspect flow switch (if used).
Inspect main burner flame and pilot burner (see F igs . 13
and 14a on page 29).
Annually
A service/inspection of the boiler and the system is
mandatory once a year.
Boiler servicing — heat exchanger cleaning
Before heating season starts, boiler/burner should be
serviced by a qualified service agency. The owner should
establish a service contract with a qualified serv ice agency.
5167 450 v1.4
In order to ensure that the boiler
continues t o operate at its peak
performance, s afety and efficiency,
observe and follow the
recommendations for maintenance,
inspection and service routine. Early
detection of problems and their
immediate repair will usually result in
less damage, lower repair cost and
continued safe operation.
CAUTION
To Next Page
Loading...
Need help?
General