Volvo Penta D2-75 - Maintenance and Care

28
Maintenance schedule
Every 200 operating hours or at least once a year
● Reverse gear. Oil change ...............................................................................page 49
● Reverse gear (HS25) Cleaning the oil filter .....................................................page 49
● Reverse gear. Lubricate propeller shaft seal...................................................page 52
● S-drive. Oil change ........................................................................................page 48
● S-drive/Reverse gear. Checking corrosion protection ..................................... page 50
Every 500 operating hours or at least once a year
● Engine oil. Replace ........................................................................................page 32
● Oil filter. Replace ...........................................................................................page 32
● Fuel filter. Replace .........................................................................................page 41
● Fuel pre-filter. Replace ...................................................................................page 41
● Idling speed. Check .......................................................................................page 31
● Coolant
1)
. Replace .........................................................................................page 35
● Seawater pump. Check impeller ..................................................................... page 36
● Vacuum valve. Cleaning ................................................................................page 37
1)
If the freshwater system is filled with an anti-corrosion agent mixture it must be changed every year.
If the freshwater system is filled with an antifreeze (glycol) mixture it must be changed every other year.
Every 500 operating hours or at least once every two years
● Air Cleaner (ACL). Cleaning ...........................................................................page 31
● Coolant
1)
. Replace .........................................................................................page 35
● Heat exchanger. Cleaning .............................................................................. page 35
Injectors. Test pressure ............................................................................. not shown
Valve clearance. Adjustment ..................................................................... not shown
1)
If the freshwater system is filled with an anti-corrosion agent mixture it must be changed every year.
If the freshwater system is filled with an antifreeze (glycol) mixture it must be changed every other year.
Every 500 operating hours or at least every fifth year
Reverse gear. Replacing propeller shaft seal.............................................. not shown
Every seventh year
S-drive. Replacing rubber seal between drive and hull ................................ not shown
7742957 - Downloaded from www.volvopenta.com 22/09/2008 11:33:23