A
Every 200 hours / at Least Every 12th Month
Coolant level and antifreeze mixture I
Crankcase ventilation filter I
Air Filter I
Fuel pre-filter and fuel fine filter R
Drive belts, wear and tension I
Compressor, oil level I
Seawater pump impeller I
Sacrificial anodes: charge air cooler, heat exchanger and exhaust pipe
(1)
I
Drive-unit and transom. Corrosion protection (sacrificial anodes) I
Reverse gear, oil and filter R
Engine with reverse gear. Propeller shaft seal I
Outboard drive, oil R
Outboard drive. Lubricate propeller shaft and check for damage and corrosion. Visual
inspection of propeller shaft sealing.
I
Outboard drive, universal joint bellow I
Outboard drive, steering cylinder bellow and ground strap I
Outboard drive, steering positioning sensors I
Outboard drive. Hydraulic cylinders, hoses and fittings I
Outboard drive, rubber hoses and clamps I
Outboard drive, exhaust bellow I
Exhaust pipe / hose I
Engine and transmission, oil / fuel / water leakage (at least 1200 rpm) I
Engine and transmission, touch up paint as required I
Batteries, electrolyte level I
1) Once every year
B
Every 400 Hours / at Least Every 5 Years
Outboard drive, fork bushings I
Outboard drive, shift mechanism and cable I
Outboard drive, pressure and vacuum testing
(1)
I
Outboard drive, hydraulic valve oil and oil filter (Steering Control Unit) R
Outboard drive. Lubricate propeller shaft splines and fasteners I
Hydraulic tie-bar oil R
1. Vacuum testing is unsuitable with the drive in water.
Maintenance Schedule
68 47702599 12-2011
47702599 - Downloaded from www.volvopenta.com 23/11/2015 22:01:35
To Next Page
Loading...
