EasyManua.ls Logo

Weber Genesis 54406 - User Manual

Weber Genesis 54406
26 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
54406 12/31/12 LP
US ENGLISH
#54406
330
Guía del Propietario del Asador de Gas Propano Licuado - Pg. 27
Mode d’emploi du grill à gaz PL - Pg. 51
GAS GRILL
LP Gas Grill Owner’s Guide
YOU MUST READ THIS OWNER’S GUIDE
BEFORE OPERATING YOUR GAS GRILL.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury,
death, or damage to property.
WARNING:
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
WARNING: Do not ignite this appliance
without first reading the BURNER
IGNITION sections of this manual.

Table of Contents

Questions and Answers

  • G
    Gabriela Collins MDAug 12, 2025
    What to do if my Weber Grill burners don't ignite?
    • A
      alexander06Aug 12, 2025
      To reset the excess flow safety device, close the LP tank valve and turn all burner control knobs to the OFF position. Open the grill lid. Slowly turn the LP tank valve until it is completely open. Wait several seconds, then ignite your Weber Grill, referring to “MAIN BURNER IGNITION”. The excess flow safety device, which is part of the barbecue to cylinder connection, may have activated.
  • J
    jacobhansenAug 16, 2025
    What to do if Weber Grill burner does not ignite when pushing the igniter button?
    • D
      David BrownAug 16, 2025
      If match lighting is successful, the problem lies in the ignition system. Refer to “ELECTRONIC IGNITION SYSTEM OPERATIONS”. Verify that the battery is in good condition and installed correctly. Refer to “ELECTRONIC IGNITER INSPECTION”. Be sure that wires are correctly inserted into terminals on the ignition box. Refer to “ELECTRONIC IGNITION SYSTEM OPERATIONS”. Remove plastic wrapping, if there is plastic wrapping around the new battery.
  • J
    Jacob StewartAug 19, 2025
    Why is the flame pattern erratic on my Weber Grill burner?
    • P
      Paul FrazierAug 19, 2025
      If the burner flame pattern on your Weber Grill is erratic, with a low flame when the burner is on HI, and flames not running the whole length of the burner tube, clean the burners. Refer to “MAINTENANCE”.
  • R
    rachael21Aug 23, 2025
    What to do if Weber Grill burner does not light or flame is low?
    • X
      xadamsAug 23, 2025
      Refill LP cylinder, if LP fuel is low or empty. Straighten fuel hose, if fuel hose is bent or kinked.
  • J
    jamestaylorAug 27, 2025
    Why do Weber Genesis 54406 Grill burners burn with a yellow or orange flame?
    • J
      Justin OnealAug 27, 2025
      Clean Spider/Insect screens .Refer to “ANNUAL MAINTENANCE”.
  • L
    Laura FloresAug 30, 2025
    Why does the inside of my Weber Genesis 54406 lid appear to be peeling?
    • D
      Daniel BentleyAug 31, 2025
      Clean thoroughly the inside of the lid of your Weber Grill, referring to “CLEANING”. The inside of the lid is porcelain enamel or stainless steel, and is not painted. It cannot “peel”. What you are seeing is baked on grease that has turned to carbon and is flaking off. THIS IS NOT A DEFECT.
  • H
    Heather BennettSep 3, 2025
    How to stop flare-ups when using Weber Genesis 54406?
    • A
      Anna SanchezSep 3, 2025
      To address flare-ups on your Weber Grill: * Ensure you are preheating with all burners on HI for 10 to 15 minutes. * Clean cooking grates, heat deflectors, and Flavorizer® bars thoroughly, referring to “CLEANING,” if they are heavily coated with burned-on grease. * Clean the slide-out grease tray if it's dirty and preventing grease from flowing into the catch pan.
  • K
    Kevin SchultzSep 7, 2025
    How to align Weber Genesis 54406 cabinet doors?
    • M
      melissamossSep 7, 2025
      To fix cabinet doors that are not aligned on your Weber Grill, loosen the adjustment nut/s and slide the door/s until aligned. Then, tighten the nut. This adjustment can be made by checking the adjustment pin on the bottom of each door.

Summary

Safety Warnings and Dangers

Exploded View Diagram

Exploded View Parts List

Product Warranty Information

General Grill Instructions

Canadian Installation Requirements

Specific installation guidelines for Canada, adhering to local codes.

Operating the Gas Grill

Instructions and warnings for safe operation of the gas grill.

Storage and Non-Use Procedures

Guidance on proper storage and what to do when the grill is not in use.

Gas Fuel and Cylinder Instructions

Safe Handling of Propane Gas Cylinders

Essential safety tips for handling liquid propane gas cylinders.

Important LP Cylinder Information

Leak Check Preparation Steps

Steps to prepare the grill and cylinder for leak checking.

Performing Gas Leak Checks

Refilling the Propane Cylinder

Pre-Use Grill Inspection and Setup

Checking Fuel Level Indicator

How to check the propane fuel level using the indicator.

Grease Tray and Drip Pan Maintenance

Instructions for cleaning and maintaining the grease collection system.

Electronic Igniter System Check

Verifying the condition and installation of the igniter battery.

Fuel Hose Inspection Guide

How to inspect the fuel hose for damage before use.

Main Burner Ignition and Usage

Main Burner Electronic Ignition

Step-by-step guide for igniting the main burners using electronic ignition.

Main Burner Manual Ignition Procedure

Sear Station Burner Operation

Igniting the Sear Station Burner

Instructions for igniting the Sear Station® burner, including manual.

Understanding the Searing Technique

Explanation of the searing technique and its benefits for cooking.

Operating the Sear Station Burner

How to use the Sear Station® burner for optimal cooking results.

Grilling Tips and Helpful Hints

Grill Preheating Guidelines

Instructions and importance of preheating the grill before cooking.

Covered Cooking Techniques

Best practices for cooking with the grill lid closed for even heat.

Managing Drippings and Grease

How to manage grease and drippings to prevent fires.

Flavorizer System Functionality

Explanation of how the Flavorizer® system enhances flavor.

Side Burner Ignition and Usage

Side Burner Electronic Ignition

Step-by-step guide for igniting the side burner using electronic ignition.

Side Burner Manual Ignition Procedure

Troubleshooting Common Issues

Side Burner Troubleshooting Guide

Solutions for problems encountered with the side burner.

Grill Maintenance Procedures

Cleaning Grill Components

Detailed instructions for cleaning various parts of the grill.

Spider and Insect Screen Maintenance

Inspection and cleaning of screens to prevent burner obstruction.

Burner Tube Cleaning and Replacement

Control Panel Removal for Access

Steps to safely remove the control panel for maintenance access.

Burner Tube Removal and Reinstallation

Cleaning Burner Tubes

Procedure for cleaning debris and ensuring proper burner function.

Reinstalling Burner Tubes Correctly

Steps for properly reinstalling burner tubes and igniter wires.

Electronic Ignition System Operation

Side Burner Maintenance Procedures

Annual Inspection of Spider;Insect Screens

Annual checks for screens to ensure proper gas flow.

Weber Genesis 54406 Specifications

General IconGeneral
BrandWeber
ModelGenesis 54406
CategoryGrill
LanguageEnglish

Related product manuals