Westinghouse iGen4500DFc User Manual (English)

Questions and Answers:

J
jeffery05Aug 4, 2025
How to fix a Westinghouse iGen4500DFc Portable Generator that will not start?
- D
  davidrodriguezAug 5, 2025
  If your Westinghouse Portable Generator won't start, there are several potential causes. First, ensure that the generator has enough fuel by refueling it. If the fuel is old or bad, drain the tank and refill it with fresh gasoline. A dirty air filter can also prevent the engine from starting, so clean it. Check the engine oil level and add oil if it's low. If the spark plug is wet with fuel, wait five minutes, turn the Run/Stop switch to OFF, and pull the recoil handle rapidly several times. If it still doesn't start, remove and dry the spark plug. The spark plug may be faulty, fouled, or improperly gapped, so gap or replace it and reinstall. Ensure that the choke is fully open or closed. Also, make sure that the CO sensor is in its original configuration and has not been activated.
B
Brenda JohnsonAug 9, 2025
Why does my Westinghouse Portable Generator start, then shuts down?
- B
  Brian RobertsonAug 9, 2025
  If your Westinghouse Portable Generator starts and then shuts down, the possible reasons are: it may be out of fuel, so refuel it. The engine oil level may be incorrect, so check it. The air filter may be dirty, so clean it. The fuel may be contaminated, so drain the fuel tank and refuel with fresh gasoline.
J
John ReynoldsAug 14, 2025
What to do if Westinghouse iGen4500DFc runs rough or bogs when load applied?
- R
  Ryan SmithAug 14, 2025
  If your Westinghouse Portable Generator is running rough or bogs when a load is applied, start by cleaning the air filter. The generator might be overloaded, so unplug some devices. Also, a faulty power tool or appliance could be the cause; replace or repair it, and then stop and restart the engine.
J
Joanna HenryAug 19, 2025
Why does my Westinghouse iGen4500DFc lack power?
- J
  joe00Aug 20, 2025
  If your Westinghouse Portable Generator lacks power, the air filter may be restricted, so clean or replace it. If the fuel is bad, drain the fuel tank and refuel with fresh gasoline.
J
Jeremy WalshAug 25, 2025
What to do if there is no power at AC receptacles of Westinghouse iGen4500DFc Portable Generator?
- C
  Cheryl RobertsAug 25, 2025
  If there is no power at the AC receptacles of your Westinghouse Portable Generator, check the AC loads and reset the circuit breakers if they have tripped. A faulty power tool or appliance could also be the issue; replace or repair it and then restart the engine.
W
William OconnorAug 29, 2025
Why is there frost on the propane tank of my Westinghouse iGen4500DFc Portable Generator?
- J
  Joel JohnsonAug 29, 2025
  If you notice frost on the propane tank or regulator of your Westinghouse Portable Generator, it may be due to the propane tank temperature dropping below the dew point, especially in humid conditions; if all equipment is functioning normally, no correction is needed. If you suspect your propane fuel tank is not equipped with an Overfilling Prevention Device (OPD), discontinue operation immediately and replace the propane fuel tank with a propane tank equipped with a an OPD. If you suspect your propane fuel tank has been overfilled, discontinue operation immediately and return the propane fuel tank to the place of purchase or refilling.

Westinghouse iGen4500DFc Specifications

General

Brand	Westinghouse
Model	iGen4500DFc
Category	Portable Generator
Language	English

Summary

Introduction to Westinghouse iGen4500DFc

Generator Specifications

Detailed technical specifications for the Westinghouse iGen4500DFc generator.

Product Registration Guide

Instructions and methods for registering the generator for warranty coverage.

Safety Information and Guidelines

Safety Definitions

Explanation of safety terms like DANGER, WARNING, CAUTION, and NOTICE.

Safety Symbols Explained

Explanation of hazard symbols used in the manual and on the generator.

Essential Safety Instructions

Essential guidelines for safe operation and handling of the generator.

General Safety Precautions

Broad safety rules covering operation, maintenance, and general handling.

Fuel Safety Guidelines

Precautions and guidelines related to handling gasoline and propane.

Propane Fuel Safety

Specific safety warnings and handling procedures for propane fuel.

Safety Labels and Decals

Description and location of safety labels and warnings on the generator.

CO Sensor and Safety

Information about the carbon monoxide sensor and its safety functions.

Generator Components Overview

Generator Components Identification

Identification and description of external generator parts.

Data Center Display

Explanation of the digital display and its functions.

Control Panel Components

Detailed breakdown of the generator's control panel elements.

Assembly and Initial Setup

Carton Contents List

List of items included in the generator packaging.

Initial Engine Oil Fill

Procedure for adding engine oil before the first use.

Fuel Requirements and Handling

Guidance on fuel types, requirements, and safe handling.

Connecting the Propane Tank

Instructions for safely connecting a propane tank.

Connecting the Battery

Steps for connecting the generator's battery.

Generator Operation Procedures

Generator Location Guidelines

Recommendations for safe and optimal placement of the generator.

Generator Grounding

Instructions and importance of grounding the generator for safety.

High Altitude Operation

Considerations and adjustments for operating the generator at high altitudes.

Remote Start Function

How to use and set up the remote start function.

Reprogramming Remote Start

Procedure to reprogram or re-pair the remote start key fob.

Fuel Selector Switch Operation

Instructions on how to switch between gasoline and propane fuel.

Engine Break-In Period

Guidelines for breaking in the generator during the initial use period.

Before Starting the Generator

Pre-operation checks and requirements before starting the generator.

Starting the Engine (Gasoline)

Step-by-step guide to starting the engine using gasoline.

Starting the Engine (Propane)

Step-by-step guide to starting the engine using propane.

Switching Fuel Sources

Procedure for changing the fuel source while operating the generator.

Stopping the Engine

Instructions on how to safely shut down the generator.

Overload Reset Procedure

Procedure for resetting the generator after an overload condition.

Eco Mode Operation

Explanation and usage of the Eco mode for fuel efficiency and noise reduction.

Generator Capacity Management

Understanding the generator's power output limits and load management.

Power Management Best Practices

Best practices for connecting and managing electrical loads to the generator.

Extension Cord Usage

Safety precautions and guidelines for using extension cords with the generator.

Extension Cord Sizing Guide

Guidelines for selecting appropriate extension cord gauges for electrical loads.

Parallel Operation

Information on linking two generators for combined running and peak power output.

Transporting the Generator

Safe procedures for moving and transporting the generator.

Generator Maintenance Procedures

Maintenance Schedule

Recommended maintenance intervals for optimal generator performance.

Engine Service Cover Access

Instructions for accessing internal engine components for maintenance.

Air Filter Maintenance

Procedure for cleaning and maintaining the air filter element.

Engine Oil Level Check

How to check and maintain the correct engine oil level.

Engine Oil Change Procedure

Step-by-step guide for changing the engine oil.

Spark Plug Maintenance

Procedure for inspecting and replacing the spark plug.

Spark Arrestor Service

Instructions for cleaning and servicing the spark arrestor screen.

Battery Maintenance

Guidelines for maintaining the generator's battery health.

Battery Replacement

Procedure for replacing the generator's battery.

Storage Preparation

Steps for preparing the generator for storage.

Draining the Float Bowl

Procedure to drain fuel from the carburetor float bowl.

Draining the Fuel Tank

Instructions for draining the fuel tank for extended storage.

Valve Clearance Adjustment

Procedure for checking and adjusting valve clearance.

Manual Choke Operation

How to manually set the choke for starting the engine.

Troubleshooting Common Issues

Engine Will Not Start

Causes and solutions for the engine failing to start.

Engine Starts, Then Shuts Down

Troubleshooting steps when the engine stops unexpectedly after starting.

Engine Lacks Power

Diagnosing and resolving issues with reduced engine power.

Engine Runs Rough or Bogs

Solutions for poor engine performance or stalling when load is applied.

No Power at AC Receptacles

Troubleshooting steps when no power is delivered to AC receptacles.

Propane Tank Frosting

Addressing potential issues with propane tank condensation or frosting.

Propane Fuel Smell Issues

Identifying and resolving propane fuel leaks or unusual odors.

Propane Performance Issues

Troubleshooting issues specific to propane operation and engine stalling.

Exploded Views and Parts Lists

Engine Exploded View

Diagram showing the internal components of the engine.

Engine Parts List

List of part numbers and descriptions for the engine assembly.

Generator Exploded View

Diagram showing the external components of the generator.

Generator Parts List

List of part numbers and descriptions for the generator assembly.

Generator Parts List Continued

Continuation of the generator parts list with additional component details.

Generator Schematics

Electrical Schematics

Wiring diagrams and schematic representations of the generator's electrical system.

Related product manuals

Westinghouse iGen4500DF

95 pages

Westinghouse iGen4500

52 pages

Westinghouse iGen4500c

32 pages

Westinghouse iGen4500s

56 pages

Westinghouse iGen4000c

80 pages

Westinghouse iGen4000DFc

92 pages

Westinghouse iGen2200

56 pages

Westinghouse iGen2500

56 pages

Westinghouse iGenTent

22 pages

Westinghouse iGen1200

56 pages

Westinghouse iGen5000DFc

92 pages

Westinghouse iGen11000DFc

32 pages

Westinghouse iGen4500DFc User Manual

Table of Contents

Questions and Answers:

Westinghouse iGen4500DFc Specifications

Summary

Introduction to Westinghouse iGen4500DFc

Generator Specifications

Product Registration Guide

Safety Information and Guidelines

Safety Definitions

Safety Symbols Explained

Essential Safety Instructions

General Safety Precautions

Fuel Safety Guidelines

Propane Fuel Safety

Safety Labels and Decals

CO Sensor and Safety

Generator Components Overview

Generator Components Identification

Data Center Display

Control Panel Components

Assembly and Initial Setup

Carton Contents List

Initial Engine Oil Fill

Fuel Requirements and Handling

Connecting the Propane Tank

Connecting the Battery

Generator Operation Procedures

Generator Location Guidelines

Generator Grounding

High Altitude Operation

Remote Start Function

Reprogramming Remote Start

Fuel Selector Switch Operation

Engine Break-In Period

Before Starting the Generator

Starting the Engine (Gasoline)

Starting the Engine (Propane)

Switching Fuel Sources

Stopping the Engine

Overload Reset Procedure

Eco Mode Operation

Generator Capacity Management

Power Management Best Practices

Extension Cord Usage

Extension Cord Sizing Guide

Parallel Operation

Transporting the Generator

Generator Maintenance Procedures

Maintenance Schedule

Engine Service Cover Access

Air Filter Maintenance

Engine Oil Level Check

Engine Oil Change Procedure

Spark Plug Maintenance

Spark Arrestor Service

Battery Maintenance

Battery Replacement

Storage Preparation

Draining the Float Bowl

Draining the Fuel Tank

Valve Clearance Adjustment

Manual Choke Operation

Troubleshooting Common Issues

Engine Will Not Start

Engine Starts, Then Shuts Down

Engine Lacks Power

Engine Runs Rough or Bogs

No Power at AC Receptacles

Propane Tank Frosting

Propane Fuel Smell Issues

Propane Performance Issues

Exploded Views and Parts Lists

Engine Exploded View

Engine Parts List

Generator Exploded View

Generator Parts List

Generator Parts List Continued

Generator Schematics

Electrical Schematics