Zundapp Z101 - Page 71

Operating Manual – Folding bike with electric drive up to 250 W
04.02.2022 REV 2.1
71
Interval
Component
Action
Before every trip
Brakes
Check the proper function of your brakes
After every long or hard
use or every 20 riding
hours
Complete bike
Inspect the bike for damage.
Have the bike repaired by a qualified
dealer, if necessary.
Weekly
Brakes
Check the proper power cut-off function
of the brake levers
Monthly or every 150
km
Chain and sprockets
Clean the chain and sprockets, then relu-
bricate them.
Every six months
Tyres and wheel rims
Inspect your tyres for visible damage and
the wheel rims, spokes and spoke nipples
for damage and correct fitting. Adjust, if
necessary, or replace defective compo-
nents.
Every 3 500 km or every
year
Brakes
Replace the brake pads. Inspect the
wheels for lateral runout and wear on
the brake flanks.
Thoroughly clean the brake flanks on the
wheel rims.
Inspect the brake cables for rust and
damage; replace, if necessary.
Inspect the brake levers for proper func-
tion and damage.
Every 3 500 km or every
two years
Chain
Replace the chain with a new one
Every 6 000 km or every
three years
Inner tubes and tyres
Replace the inner tubes and tyres with
new ones
Every 8 000 km or every
four years
Drive unit
Replace the chain, bolt-on cassette and
complete crankset with new components
Every 14 000 km or
every eight years
Wheels
Replace the complete wheels
As necessary
Frame, forks, wheels and
pedals
Remove the coarse dirt with a suitable
brush.
Clean the components with a damp cloth
and mild soapy water.