3M G5 - Disconnect and Remove XT-1 Basestation

Table of Contents
3M™ Drive-Thru Systems Model G5 and Model XT-1
Installation Manual
March 2014 – Revision 2.0
Page 3 of 74
Table of Contents
Overview ..................................................................................................................................... 5
Safety Information ................................................................................................................... 5
Other Conventions ................................................................................................................... 6
Installation ................................................................................................................................ 10
Overview of Installation ......................................................................................................... 10
Required Materials (Not Supplied) ........................................................................................ 10
Design the Installation ........................................................................................................... 10
Install the Battery Charger ..................................................................................................... 13
Install the Order Point Speaker and Microphone Assemblies ............................................... 16
Install the Vehicle Detector(s)................................................................................................ 16
Assemble the 3M™ Drive Thru Headset G5 ......................................................................... 16
Install the Base Station .......................................................................................................... 19
Installing Accessory Boards in the Base Station ................................................................... 30
Power Up ............................................................................................................................... 34
Configuration ........................................................................................................................... 35
Enter Configuration Mode...................................................................................................... 35
Navigating the Base Station Display ..................................................................................... 35
Configuring with a Computer ................................................................................................. 37
Change Basic Volume Settings ............................................................................................. 39
Change the Monitor Volume .................................................................................................. 40
Change the Night Volume ..................................................................................................... 41
Registering Headsets ............................................................................................................ 42
Change Noise Reduction Level ............................................................................................. 43
Set System Date and Time.................................................................................................... 44
Change Global Settings ......................................................................................................... 44
Order Taking Modes Setup ................................................................................................... 49
Change Site Scheduling ........................................................................................................ 50
Change Site Information ........................................................................................................ 51
Change Self Monitoring ......................................................................................................... 51
Change Passcodes ............................................................................................................... 51
Two Base Station Setup ........................................................................................................ 52
Installer Setup ........................................................................................................................ 52
Factory Setup (Restore Factory Defaults) ............................................................................. 53
Create and Load Templates .................................................................................................. 53
Reboot System ...................................................................................................................... 53
Check the Revision Levels .................................................................................................... 53
Activate the Backup Intercom ................................................................................................ 53
Change the Microphone Preamp Gain .................................................................................. 54
Installer Access ..................................................................................................................... 54
Troubleshooting ...................................................................................................................... 55
Headset Indicator Lights ........................................................................................................ 55
General Troubleshooting ....................................................................................................... 57
Battery and Battery Charger Troubleshooting ....................................................................... 59
Appendix: Declaration of Conformity .................................................................................... 60
Appendix: Base Station Specifications ................................................................................. 61
Physical ................................................................................................................................. 61
Electrical ................................................................................................................................ 61
Functional .............................................................................................................................. 61
Appendix: Best Practices ....................................................................................................... 62
PreAmp Setting ..................................................................................................................... 62
Volume Control ...................................................................................................................... 62
Optimizing the Installation ..................................................................................................... 62
Dealing with Delay/Echo ........................................................................................................ 63