achilles A23S - Warning Indicators and Alarms; Checkpoints after Starting the Engine

26
 LCD Display for Warning
 Remaining fuel warning
When the fuel level is very low, the
3
lamp
(yellow) starts flashing and the following
message appears in the display.
 Battery charge warning
If the charging system fails, the
3
lamp (red)
starts flashing and the following message
appears in the display.
 Engine oil pressure low warning
When the engine oil pressure drops too low,
the
3
lamp (red) starts flashing and the
following message appears in the meter.
Immediately stop the engine and check the
engine oil level.
 Warning Lamp
 The warning lamp is used to indicate
broken wire, short-circuit, fuel shortage
and other problems.
NOTE:
 Warnings and errors are displayed and
an alarm buzzer beeps.
 The warning lamp starts flashing in red if
any trouble occurs. If the system gets in
warning signal, the warning lamp starts
flashing in yellow.
(1) Warning lamp (red, yellow)
(2) LCD display
IMPORTANT:
 Do not just look at the meter, but also
carry out the inspection and correction
accordingly.
NOTE:
 Let your ACHILLES dealer inform
you of details concerning care and
maintenance.
 Checkpoints after Starting the
Engine
After starting the engine, but before starting
operation, check two following points:
1. Put the throttle lever in "LOW" position
and let the engine idle for approx. 5
minutes. This allows the engine lubricant
to warm up and penetrate every part of
the engine.
Note:
 This idling is usually called "Warm-
up".
2. Once the engine has warmed up, check:
 the warning lamp "Engine oil
pressure" has gone out.
 the warning lamp "Battery charge"
goes out when engine speed is
increased.
 the color of the exhaust is normal and
no abnormal noises or vibrations are
heard or felt.
 no fluid is leaking from pipes or
hoses.
 Should any following conditions occur,
stop the engine immediately.
 The engine rpm's increases or decreases
suddenly.
 Sudden abnormal noises are heard.
 Exhaust is black.
 Alarm lamp for engine oil lights up
during operation.
IMPORTANT:
 In these cases, the excavator must be
checked and serviced by your local
ACHILLES dealer.