Alliance Laundry Systems YTEE5ASP173TW01 - Default Chapter; Table of Contents

1
Table of
Contents
Section 1 – Safety Information ...............................................................3
Locating an Authorized Servicer...........................................................4
Section 2 – Introduction ..........................................................................5
Customer Service...................................................................................5
Nameplate Location...............................................................................5
Model Identification ..............................................................................6
Theory of Operation ..............................................................................7
Section 3 – General Troubleshooting.....................................................8
1. Keypad Combinations...................................................................8
2. Factory Test Procedure ...............................................................10
3. Motor Circuit...............................................................................16
4. Dipswitch Configuration.............................................................17
5. Troubleshooting Knocking Noise ...............................................18
6. Explanation of LEDs on Drive Control ......................................18
7. Door Fails to Unlock at End of Cycle.........................................18
8. No Spin .......................................................................................18
9. Excessive Vibration and/or Noise During Spin ..........................20
10. Excessive Cycle Time.................................................................21
Section 4 – Dryer Control Troubleshooting ........................................22
7. Dryer Error Code Listing ............................................................22
8. Dryer Motor Does Not Run ........................................................24
9. Dryer Stops in Cycle; Quits After the First Few Loads;
Has a Burning Smell; Cycles On Motor Thermal Protector .......26
10. Dryer Motor Runs But Cylinder Does Not Turn ........................27
11. Dryer Motor Does Not Stop .......................................................28
12. Dryer Runs Only When Door is Open ........................................29
13. Dryer Heating Assembly Does Not Heat or
Burner Does Not Ignite...............................................................30
14. Igniter Does Not Glow (Gas Supply Sufficient)
– Gas Dryer Models ....................................................................32
15. Burner Ignites and Goes Out Repeatedly
– Gas Dryer Models ....................................................................33
16. Igniter Glows But Burner Does Not Ignite
– Gas Dryer Models ....................................................................34
17. Dryer Heater Assembly or Burner Shuts Off Prematurely .........35
18. Dryer Heater Assembly or Burner Repeatedly Cycles
Off On Limit Thermostat ............................................................36
19. Dryer Heater Assembly or Burner Does Not Shut Off ...............38
20. Clothes Do Not Dry in Dryer......................................................39
21. Timer Does Not Advance in Automatic Cycle ...........................40
22. Clothes Are Too Hot When Removed From Dryer ....................41
23. Excessive Chattering or Vibrating Noise in Dryer .....................42
24. Excessive Humming or Whistling Noise in Dryer......................43