HEBT-5V BUN TOASTER
1
P/N 1011112 Rev W 05/22
McDonald’s
BUN TOASTER
HEBT-5V
MFG. NO. 9210840, 841, 842, 843, 844, 845, 846, 847, 848, & 849
Place this manual in the Toaster section
of your Equipment Manual.
Manufactured exclusively for
McDONALD’S
®
BY
ANTUNES
180 KEHOE BLVD.
CAROL STREAM, ILLINOIS 60188, U.S.A.
PHONE: +1-630-784-1000
TOLL FREE: +1-877-392-7854
FAX: +1-630-784-1650
www.antunes.com
This manual is for the exclusive use of licensees and employees of McDonald’s Systems, Inc..
© McDonald’s Corporation All Rights Reserved
Owner Information ................................................................. 2
General ................................................................................. 2
Service/Technical Assistance ................................................ 2
Warranty Information ............................................................. 2
Specications ........................................................................ 3
Electrical Specications & Plug Conguration ...................... 3
Pass Through Time ............................................................... 3
Dimensions ........................................................................... 3
Important Safety Information ............................................... 4
Installation .............................................................................. 5
Unpacking ............................................................................. 5
Location................................................................................. 5
Operation ................................................................................ 6
Language Selection .............................................................. 6
Operating Instructions ........................................................... 6
Club Platen OFF units (Mfg. # 9210844 & 9200847) ............ 7
Programming ......................................................................... 8
Control Panel LEDs............................................................... 8
Settings ................................................................................. 8
Adjusting Toast Quality .......................................................... 8
Factory Reset ........................................................................ 8
Maintenance ........................................................................... 9
Belt Inspection Information.................................................... 9
Troubleshooting ...................................................................11
Replacement Parts .............................................................. 15
Wiring diagram .................................................................... 22
Scan with mobile device or enter URL
for product and service information.
HEBT-5V
http://tiny.cc/ajaHEBT5V
LIMITED WARRANTY
Antunes provides the following limited warranty to the original purchaser of all McDonald’s Equipment.
All components are warranted against defects in the material and workmanship for a period of two (2) years. If any part becomes inoperable during the period of this
warranty, Antunes will pay labor costs to an Authorized Service Agent to replace the part plus travel expenses.
Antunes reserves the right to make changes in design or add improvements on any products. The right is always reserved to modify Equipment because of factors
beyond our control and government regulation. Changes to Equipment do not constitute a warranty charge.
This warranty is exclusive and is in lieu of all other warranties, expressed or implied, including any implied warranty of merchantability or fitness for a particular pur-
pose, each of which is expressly disclaimed. The remedies described above are exclusive, and in no event shall or any of its Divisions be liable for special conse-
quential or incidental damages for the breach or delay in the performance of this warranty.
WARRANTY EXCLUSIONS
• The cost of installation.
• Equipment that has been damaged due to shipment. Purchaser should make
damage claim directly upon carrier.
• Alteration, misuse, abuse.
• Improper storage or handling.
• Improper maintenance.
• Failure to follow proper installation instructions, including electrical connec-
tion.
• Improper or unauthorized repairs.
• Scheduled Maintenance procedures as outlined in your MRC Card.
• Consumables such as Grill Covers (Release Sheets), gaskets, Conveyor Belt
Wraps, O-rings, removal of links, and light bulbs.
• Freight, foreign, excise, municipal, or other sales or use taxes.
• Consequential damages such as loss of profit, loss of time, the cost of repair-
ing or replacing other property which is damaged, or any other incidental
damage of any kind.
Angular Bun Feeder
shown not used
on all units.
Table of Contents
To Next Page
General
