Axis A20 - Page 80

Item No. Service First 10 hours Every 50 hours Every 100 hours Annually
1. Change engine oil and filter *** *** ***
Pennzoil Marine 15W40, Pennz #PZ-3, AC PF-25
2. Change transmission oil and filter ***
Dextron III w/Mercon
3. Ski Vee ***
ATF
4. Change fuel filter, Motor / Gas tank *** 5. Change Spark plugs ***
Indmar Engines MUST use AC MR43LTS or 41-932 Platinum
6. Engine tune up ***
(Cap, Rotor, Plugs)
7 Clean for change flame arrestor *** 8 Inspect belts, hoses and clamps *** ***
Tight?
9. Shaft alignment *** ***
Within .003
10. Inspect spark plug wires *** 11. Inspect Raw water pump impeller *** ***
(change annually)
12. Inspect rudder *** ***
(lube, key-way, bolt tight)
13. Inspect Prop Shaft Packing *** ** 14. Inspect Steering Kit Assembly *** ***
(Lube, bolts tight?)
15. Check Engine Coolant (closed cooling only) ***
50:50 mix water w/ethylene glycol MUST meet GM 6038
16. Propeller Tight
(prop nut tight? key-way installed?) *** *** *** ***7
17. Lubricate starter bendix ( Lithium marine grease ) *** ***
Required Maintenance Schedule
Indmar Engines
4-21
Care and Maintenance
Chapter 4_11_Axis_ Chapter 4 doc.qxd 12/2/10 9:40 AM Page 21