Removal of Seat
• Remove ‘Side Cover’ LH.
• Pull the ‘Seat Release Cable’ (A) to release
seat lock. Keeping cable pulled, lift the
seat from rear end and slide it towards tail
lamp to remove seat assembly.
Fitment of Seat
• Match & insert the bracket ('1' of Fig. 'B')
of seat with slot ('2' of Fig. 'B') provided
below fuel tank rear mounting on chassis.
• Push seat towards fuel tank and align lock
rod ('3’ of Fig. ‘C') & seat lock ('4' of Fig.
‘C'). Then press from top the rear portion
of seat to lock it.
4
3
A
A : Seat Release Cable
Fig. B
Fig. C
2
1
Location of Parts
11
How to Ride Your Bike
12
Proper running-in is important for the better life &
trouble free performance of the vehicle.
• During first 2000 kms running-in period do not
exceed following speed limits.
(for 5 Speed)
Kms 1st 2nd 3rd 4th 5th
0 - 1000 14 22 30 37 44
1000 - 2000 17 28 38 46 55
(for 4 Speed)
Kms 1st 2nd 3rd 4th
0 - 1000 14 23 33 42
1000 - 2000 18 29 41 52
• Always keep the speed below the limits mentioned
in the table.
• Do not race the engine excessively.
• Do not sta rt movin g or race the engine
immediately after starting. Run the engine for a
minute at idle speed to give the oil a chance to
work-up into the engine.
Running IN
Riding the Bike
Before starting the vehicle & with the ignition key
‘OFF’, adhere to the following first thing in the
morning or after a long period of non-use (whichever
is the case).
Starting the Engine :
• Keep the fuel tap to ON or RES position.
• Turn ignition switch to ON position.
• Confirm that the vehicle (transmission) is in
neutral.
• Keep the throttle completely closed, push
the starter button ( ) or kick the engine
with kick starter lever.
Depress the clutch lever completely. Kick the
kick lever all the way down to its stop, briskly
a couple of times. Release the clutch lever.
CAUTION : Do not operate the starter
continuously for more than 5 sec. Wait
for 15 sec. before you re-start.
NOTE : The motorcycle is equipped with a
starter lockout switch. The vehicle can start in
any gear when clutch lever is depressed.
It is recommended to start the engine with
the transmission in neutral.
To Next Page
Loading...
Need help?
General
